2015 Ford Edge Body & Structure Problems

The contact owns a 2015 Ford Edge. The contact stated while driving 40 MPH, there was an abnormal banging sound coming from the driver's side roof panel. The contact continued driving. The contact stated that while driving on another occasion, the sound became louder. Upon arriving at the destination, the contact inspected the vehicle. The contact noticed that the driver's side roof panel and the front roof panel that was connected to the windshield had detached. The contact applied tape to the roof panels. The vehicle was taken to the dealer, where it was inspected and the dealer re-applied tape to the roof panels. The dealer referred the contact to an autobody repair shop for the repair. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 145,000.

Ford edge as far as I’m aware, have many complaints with a cracked rear taillight which builds up with water and condensation. My 2015 Ford Edge SEL has had this problem. I was told by an auto body repair shop many customers encounter this problem, it is a manufacturer defect and ford won’t hold responsibility and announce this as a recall.

vista roof has spontaneously cracked in 2 different areas. i did have my insurance company look at it. they did cover it sorta. but it has cracked again.

Rear sunroof shattered spontaneously

I’m not a car expert. However, this suv has been rusting for some time in (1) one spot. Why? Because there seems to be a manufacture defect in or on the door body structure. I am concerned that the rust my be effecting my safety when driving and May fall off eventually. Causing injury. I can not get an explanation from FORD as the why this is happening! Other than it must be a manufacturer issue/defect etc.

The Panoramic Vista Glass Sunroof on my 2015 Ford Edge shows many cracks along the front edge of the glass for no apparent reasons. This was discovered recently on a calm cloudy day. I've attached some pictures at different angles. This roof has the potential to explode if going on a high speed. I'm surprise to discovered that their is no recall issue for this model, but on other Ford Models with Panoramic Glass Sunroof. Please investigate and add this Make/Model to Ford Panoramic Vista Glass Sunfoof Recall List. No vehicle should have a roof top crack for no apparent reason. I'm afraid to even open the soft divider separating the car riders from the glass sunroof.

The car has multiple rust locations on the car and peeling at an alarming rate. Vehicle is available for inspection. In reviewing the origin report; it appears the car was built from scrape and unknown to purchaser. Door may fall off! Inspected by Liberty Ford. Sold at well above lot price. No recall yet. Door may fall off etc.

The liftgate consistently shows ajar and battery dies. Replaced liftgate latch and still doesn’t work properly.

THE FRONT PASSENGER SIDE OF THE CAR STARTED TO SHOW BUBBLING/ PEELING PAINT SEVERAL MONTHS AGO. MADE SEVERAL CONTACTS WITH DEALERSHIP TO SEE IF THEY COULD TELL ME WHY! NO HELP OR ASSISTANCE FROM THEM TO FIND OUT IF MY CAR WAS DAMAGED AND/OR REPAIRED PRIOR TO MY PURCHASE. NO RESPONSE OR ANSWER FROM THEM. IN TALKING WITH A FORD BODY REPAIR PERSON; HE SEEMS TO FEEL THE CAR DOOR WAS REPAIRED AND/OR PARTIALLY REPAIRED. AND NOW RUSTING AGAIN! HOWEVER, I HAVE ALSO BEEN TOLD THAT SEVERAL OTHER FORDS HAVE HAD RUSTING ISSUED FOR SOMETIME NOW!! POSSIBLY A RECALL ISSUE! I WOULD LIKE AN ANSWER FROM FORD ON WHY THIS HAPPENING TO FORD CARS. AND, MINE ESPECIALLY!!! SOMETHING IS NOT RIGHT IN DODGE WHEN EVERYONE AT THE ORIGINAL DEALERSHIP DID NOT RESPOND. *THIS IS NOT AN ACCIDENT ISSUE. IT'S ABOUT A QUALITY OF CAR RUSTING AWAY!

THE AREA UNDER SPARE TIRE HAS PUDDLE OF WATER AFTER RAIN.

WHILE DRIVING THIS VEHICLE, THE REAR WINDOW SHATTERED. I PULLED OVER TO CHECK THE DAMAGE AND CONCLUDED NOTHING HIT THE WINDOW TO CAUSE THIS DAMAGE. WHILE INVESTIGATING (ONLINE REPORTS AND SPEAKING WITH REPAIR SPECIALISTS) THE CAUSE OF THIS DAMAGE MAY BE RELATED TO THE HEATING STRIPS (FOR DEFROSTING) IN THE WINDOW.

MOVABLE SUNROOF WAS DISCOVERED WITH CRACK RUNNING FORE AND AFT. NO APPARENT IMPACT DAMAGE AND VEHICLE IS KEPT IN GARAGE WHEN NOT IN OPERATION.

THE PANORAMIC SUNROOF CRACKED TOWARDS THE FRONT WITH NO DAMAGE OR HIT TO CAUSE IT. AFTER RESEARCHING IT SEEMS TO BE A COMMON PROBLEM WITH THE FORD EDGE SUNROOFS.

MY WIFE WAS INSIDE AT WORK AND THE 2015 EDGE WAS JUST SITTING IN THE PARKING LOT. SHE GOT IN AFTER WORK AND STARTED THE CAR AND BOOM THE BACK WINDOW JUST SHATTERS. NOT REMOTE STARTED OR ANYTHING. IT WAS ABOUT 27DEGREES F OUTSIDE. THE WINDOW LITERALLY BROKE AT ALL 4 CORNERS. I HAVE READ THERE IS A RECALL IN CANADA FOR THIS ISSUE BUT NOT ONE HERE IN THE UNITED STATES. THIS IS A WONDERFUL WAY TO START XMAS IS WITH A $600 REPAIR BILL SINCE FORD SAYS IT'S NOT COVERED UNDER WARRANTY.

PANORAMIC SUNROOF CRACKS FOR NO REASON. THE CAR IS GARAGE KEPT AND WELL TAKEN CARE OF. MINIMAL RESEARCH HAS SHOWN THAT THIS IS A KNOWN PROBLEM BUT NO RECALL HAS BEEN ISSUED.

I OWN A 2015 FORD EDGE TITANIUM TRIM. BOTH PANORAMIC SUN ROOFS HAVE DEVELOPED CRACKS FOR NO APPARENT REASON. I BELIEVE THIS IS A SIGNIFICANT SAFETY ISSUE AS I CAN HEAR THE GLASS GRINDING AS THE CAR FLEXES WHILE DRIVING. EACH ROOF PANEL DEVELOPED THESE CRACKS AT DIFFERENT TIMES. IN NEITHER INSTANCE WAS THE CAR SUBJECTED TO UNUSUAL OR SEVERE DRIVING CONDITIONS.

BACK PART OF PANAROMIC SUNROOF HAS SPIDER CRACKS; VEHICLE HAS 40K MILES

PURCHASED A USED 2015 "CERTIFIED" FORD EDGE TITANIUM 3 MONTHS AGO NOW. THE SUNROOF WILL NOT CLOSE. I AM BEING INFORMED ITS THE SUNROOF RACKS AND THOSE ARE NOT COVERED IN EITHER MY CERTIFIED WARRANTY OR MY POWER TRAN WARRANTY. HOW CAN A SUNROOF ONLY USED 3 TIMES RACKS BREAK UNLESS THEY WERE ALREADY MESSED UP AND THE DEALERSHIP THOUGHT IT WOULD BE EASIER TO GET RID OF INSTEAD OF FIXING.

WAVY PATTERED CRACKS ON THE BACK PANEL OF PANORAMIC SUNROOF GLASS WITH NO INDICATION THAT SOMETHING FELL ON IT TO CAUSE THE CRACKS. I WAS NOT IN THE CAR WHEN IT HAPPENED AND DO NOT LEAVE MY SUNROOF SHADE OPEN ALL THE TIME, SO I CANNOT BE SURE EXACTLY WHEN THE CRACKS HAPPENED. I LEAVE THE SHADE CLOSED DURING THE HOT SUMMER MONTHS.

I WAS WAXING THE TOP OF REAR HATCH. WHEN I HEARD A CRACKING SOUND. THEN NOTICED THE PANORAMIC GLASS HAD CRACKED FOR NO APPARENT REASON.