2001 Ford F-250 Powertrain & Transmission Problems

When im in traffic, starting out driving or merging between intersections my truck decides to either hard shift or not shift at all. Several times ive had to lay on my horn in an attempt to warn oncoming vehicles that i have no power and cannot accelerate and several times it has nearly caused an accident. I purchased the truck used and have yet to take it into the dealership to have them inspect the issue though from what i’ve read thus far is that ford calls this problem “normal operation” and has been less than understanding when people attempt to have this obvious defect resolved. There are no warning lights that come on when this happens. I can have my truck inspected by whomever, whenever need be. I will also be returning to the dealer to use my warranty to help deal with this issue. The date this most recently happened causing a near miss was today, though there has been an occasional but recurring situation almost weekly.

PARKED VEHICLE AT MAIN POST OFFICE , REMOVED KEYS, I KNOW THIS BECAUSE IT HAS MY POBOX KEY ON KEY RING. I HOPPED OUT AND STATED TO WALK OFF, THEN I GLANCED A VIEW TO THE RIGHT, AND NOTICED OR THOUGHT I NOTICED, MY TRUCK ROLLING BACKWARDS. IT WAS !!! I CHASED MY TRUCK AND CAUGHT UP TO IT, AND ATTEMPTED HOP IN AND ENGAGE FOOT BRAKE. I AM TO FAT AND SLOW TO DO THAT, SO I THOUGHT QUICKLY, , AH HA, THE EMERGENCY BRAKE . I REACHED DOWN AND LET THE TRUCK ROLL THE ER BRAKE TO MY HAND, AND ENGAGE IT I CALLED THE FORD DEALER, NO KNOW ISSUES LIKE THIS HAS HAPPENED, SO I WAS TOLD. SO MAYBE THIS WAS AN 1 OFF EVENT,,,, RIGHT WRONG SEVERAL MONTH LATER, SAME THING HAPPEN, DIFFERENT LOCATION. ALTHOUGH I CATCH BEFORE I GOT OUT. THIS TIME I TOOK A VIDEO OF THE ROLL BACK, AND THE SNIFTER IN PARK, AND THE KEYS OUT

FOR THE R4100 TRANSMISSION. THE EXTERNAL TRANSMISSION FILTER CAME APART AND DESTROYED MY TRANSMISSION (FORD PART # XC3Z-7B155-BA) DEFINITELY NOT A 30,000 MILE FILTER. NOT MANY PEOPLE KNOW ANYTHING ABOUT THIS,OF WHAT I HAVE FOUND. THERE WAS A EASY 80,000 LEFT IN THE TRANS IF LINES AND OIL PORTS WEREN'T PLUGGED FROM FILTER FIBERS. #2 THE PAINT CANCER (WHITE) IS THERE ANY RECALLS OR HELP WITH THAT?

TL* - THE CONTACT OWNS A FORD F-250 SUPER DUTY, AND STATED WHILE VEHICLE WAS IN A PARKING LOT HE STEPPED ON THE CLUTCH AND THE PEDAL FELL ALL THE WAY TO THE FLOOR.*AK THE STUD TO WHICH THE CYLINDER CONNECTED TO SHEARED OFF. UPDATED 03/02/07. *JB

DT*: THE CONTACT STATED THE TRANSMISSION BECAME STUCK IN 1ST GEAR AT TIMES AND WOULD NOT UPSHIFT UNLESS THE ACCELERATOR PEDAL WAS RELEASE. THIS OCCURRED UNDER NORMAL ROAD CONDITIONS. THE NATURE OF THE FAILURE WAS PERMANENT GRADUALLY WORSENED. THE SERVICE DEALER WAS NOT ABLE TO DETERMINE THE NATURE OF THE FAILURE.

THE SPRAG CLUTCH IS BREAKING ACROSS IN TWO SECTIONS. *MR THE MATERIAL WAS MADE OUT OF A IRON/POWDER MIXTURE. THE VEHICLE WAS IN NORMAL USE WHEN THE INCIDENT OCCURRED. THE CONSUMER FELT THAT THE REPAIR SHOULD BE UNDER WARRANTY DUE TO THE LOW MILEAGE. *SC *JB

FAILURE TO REPAIR APPARENT DEFECT @4000 MILES UNDER FORD'S BUMPER TO BUMPER WARRANTY. (NAR) *PH *CB

WHILE DRIVING UPHILL AT 15-20 MPH THE DRIVER HEARD A SOUND COMING FROM THE TRANSMISSION. THE TRANSMISSION SHIFTED TO NEUTRAL, THEN THE VEHICLE ROLLED BACKWARD. AFTER STOPPING, THE DRIVER WAS UNABLE TO SHIFT TO DRIVE OR REVERSE. THE VEHICLE WAS TOWED TO THE DEALER WHERE A CLUTCH MECHANISM INSIDE THE AUTOMATIC TRANSMISSION WAS REPLACED. *NLM *SCC *JB

THE CLUTCH CYLINDER FAILED AND ENGAGED THE CLUTCH. THIS MADE THE VEHICLE TAKE OFF, SOMETIMES SENDING THE CONSUMER INTO THE INTERSECTION OF TRAFFIC. THE CYLINDER HAS BEEN REPLACED TWICE AND IT CONTINUES TO PERFORM THE SAME WAY. *JB

WHILE DRIVING THE VEHICLE THE CLUTCH BROKE. THE DEALER HAS REPLACED IT THREE TIMES BUT THE PROBLEM RE-OCCURRED. *NLM

CONSUMER STATES THAT WHILE DRIVING CAN FEEL TRANSMISSION SLIPPING. CONTACTED DEALER. TRANSMISSION FAILING. PLEASE PROVIDE MORE INFORMATION. *MR

PREVIOUS FAILURE (2ND) REPORTED UNDER ODI#759329 ON SAME SUBSYSTEM -MARCH 2002. *AK

WITHOUT WARNING THE HYDRAULIC LINE FROM THE MASTER CLUTCH CYLINDER ?TERM CAME OFF AND RENDERING THE CLUTCH COMPLETELY USELESS (PEDAL WENT TO THE FLOOR AND STAYED THERE). WAS LUCKILY IN A PARKING LOT JUST ABOUT TO PULL ONTO A HIGHWAY WITH A 4000 LB TRAILER. REALIZED HOW DANGEROUS THAT COULD HAVE BEEN. FORREST CATE FORD IN LAFAYETTE, GA SAYS THE PART THEY ARE REPLACING IT WITH IS UPDATED SO THAT THE LINE DOESN'T DO THAT. THIS SHOULD BE A RECALL. IF THAT HAPPENED ON THE HIGHWAY WITH ZERO WARNING, I COULD HAVE HAD PROBLEMS STOPPING QUICKLY OR CONTROLLING THE VEHICLE. I WAS LUCKY BUT WANT NO ONE ELSE TO BE UNLUCKY. THANK YOU.*AK

FIRST HYDRAULIC CYLINDER FAILURE OCCURRED (WHILE LIVING IN FL) ON 06 JUN 2001 (ODO: 2188 MILES) AT APPROX 30MPH. LOST USE OF CLUTCH WHILE SHIFTING BETWEEN 2ND & 3RD GEAR. HYDRAULIC CYLINDER REPLACED BY ORVILLE BECKFORD FORD UNDER WARRANTY. SECOND OCCURRENCE IS DESCRIBED EARLIER IN THIS REPORT --OCCURRED AFTER MOVING TO TX. TO BE REPAIRED BY GILLESPIE FORD, SAN ANTONIO, TX.*AK

WHILE DRIVING 55MPH AND HITTING PASSING GEAR, VEHICLE WENT INTO IDLE, IT WOULD NOT ACCELERATE. DEALER CONTACTED. *AK CONSUMER STATES RECENTLY WHEN ATTEMPTING A LANE CHANGE AT 70 MPH, THE RPMS DROPPED TO 600, CONSUMER PUMPED THE ACCELERATOR TWICE BEFORE THE ENGINE BEGAN TO ACCELERATE AGAIN, CONSUMER STATES THIS IS AN INTERMITTENT PROBLEM. *SLC

TRANSMISSION PROBLEM. WHILE DRIVING TRANSMISSION BURNED UP. CONTACTED DEALER, AND DEALER WAS NOT WILLING TO DO ANYTHING.*AK

WE HAD THIS TRUCK INTO A DEALERSHIP 9 DAYS PRIOR TO THE FIRE FOR WHAT WE THOUGHT WERE TRANSMISSION PROBLEMS, THE DEALERSHIP FAILED TO FIND ANY PROBLEM WITH OUR TRUCK AND ADVISED US THAT THERE WAS NOTHING THAT PREVENTED US FROM DRIVING IT. 9 DAYS LATER WE WERE EXPERIENCING THE SAME PROBLEMS AND FELT THE NEED TO GET ANOTHER OPINION SO WE WERE IN ROUTE TO A DEALERSHIP AND DID NOT MAKE IT DUE TO THE TRUCK FAILING AND CATCHING FIRE. TRANSMISSION FLUID ESCAPED THE FILLER TUBE AND WENT ON THE EHAUST MANIFOLD WHICH CAUSED A FLASH FIRE. WE WERE FORTUNATE TO GET OURSELVES AND OUR SMALL CHILDREN OUT OF THE TRUCK IN TIME. THE DEALERSHIP PRIOR TO THE FIRE SAID THAT IF WE WERE IN FACT HAVING TRANSMISSION PROBLEMS THAT WE WOULD HAVE SEEN THE OVERDRIVE LIGHT ON THE SHIFTER COLUMN FLASHING, THIS NEVER OCCURRED WHICH LEADS US TO BELIEVE THAT THERE MAY BE A FAILURE IN THE COMPUTER OF THIS TRUCK THAT THEY REFUSED TO FIND. WE PLEADED WITH THE SERVICE ADVISOR AT THIS DEALERSHIP TO INVESTIGATE WHAT COULD HAVE CAUSED THE PROBLEMS WE WERE EXPERIENCING AND THEY REFUSED. NOW WE HAVE A TRUCK THAT HAS BEEN AT A DEALERSHIP FOR ALMOST 90 DAYS AND THEY HAVE YET TO FIND THE CAUSE OF FIRE. AND DUE TO THE FIRE FORD MOTOR COMPANY REFUSES TO TAKE RESPONSIBILITY TO THEIR PRODUCT. THEY DENIED HELPING US AND REFERRED US TO OUR INSURANCE COMPANY. WE HAVE INCURRED A DRASTIC FINANCIAL LOSS DUE TO THIS AND FEAR BEING PUT BACK IN THIS VEHICHLE KNOWING THAT IT COULD HAPPEN AGAIN, BECAUS THE INITIAL CAUSE OF FIRE HAS NOT BEEN FOUND. WE HAVE FAUGHT A HARD FIGHT WITH ALLSTATE INSURANCE TO GET THEM TO FIX OUR TRUCK PROPERLY TO NO AVIAL. WE KNOW OF OTHERS THAT ARE EXPERIENCING SIMILAR PROBLEMS AND WE FEEL FORD NEEDS TO PAY ATTENTION TO THIS MECAHNICAL FAILURE, DUE TO FAULTY PRODUCTION OF THESE TRUCKS WITH THEIR TRANSMISSIONS.*AK

FROM THE BEGINNIG THERE WAS TROUBLE WHEN STARTING THE ENGINE (VERY LONG CRANK). THE VEHICLE WAS SERVICED AT LEAST 3 TIMES FOR THIS PROBLEM AND WAS NEVER SOLVED. THEN A FEW MONTHS LATER, WHILE DRIVING AT A SPEED OF ABOUT 70 MPH, THE ENTIRE SYSTEM SHUT OFF (ENGINE, ELECTRIC, EVERYTHING) AND AFTER A FEW TERRIFYING SECONDS IT WOULD ALL KICK BACK ON. WHEN THE ENGINE KICKED BACK ON THERE WAS A MAJOR JOLT TO THE ENGINE (AND TO THE PASSENGERS). THIS HAPPENED SEVERAL TIMES EVEN AFTER THE TRUCK WAS TAKEN IN FOR SERVICING TO "CORRECT" THE PROBLEM. LASTLY, WHILE RETURNING HOME FROM VACATION, WE NOTICED THAT THE TRUCK WAS SHIFTING HARD, LUNGING RATHER THAN SHIFTING SMOOTHLY. AFTER STOPPING FOR A TOLL AND THEN PROCEEDING THE ENGINE ALMOST CUT OUT AND WOULD NOT GO PASSED 2ND GEAR. WE WERE IN A VERY BAD SECTION OF TOWN AND THERE WAS NO WAY IN HELL WE WERE GOING TO STOP. SO WE DROVE SLOWLY TO A RELATIVES HOUSE THAT WAS CLOSEST TO WHERE WE WERE. WE HAVE CONTACTED FORD'S CUSTOMER SERVICE DEPARTMENT IN THE PAST AND WERE NOT AT ALL SATISFIED WITH THEIR HANDLING OF THE SITUATION. ALL THEY DID WAS CALL THE DEALERSHIP AND RELAY THE SAME INFORMATION WE HAD ALREADY GIVEN THEM. NOW WE ARE BEING TOLD THAT FORD MUST PUT IN A WHOLE NEW "DIFFERENT" TRANSMISSION, WHY? THEY MUST ALREADY BE AWARE OF THE PROBLEM BECAUSE WE WERE TOLD BY ONE OF THEIR MECHANICS "YEAH, WE HAD A COUPLE OF OTHER TRUCKS COME IN WITH THE SAME PROBLEM. THEY WERE DIESELS TOO". HMMM.*AK

HOSE BLEW OUT OF THE BOTTOM OF CLUTCH MASTER CYCLINDER DUE TO THE KEEPER PIN MISSING. THIS CAUSED THE CLUTCH PEDAL TO GO TO THE FLOOR AND REMAIN THERE. IF THERE WOULD HAVE BEEN AN OBSTICLE IN FRONT OF THE VEHICLE IT WOULD HAVE BEEN HIT.

CLUTCH HOSE LINE THAT RUNS FROM THE MASTER CYLINDER DOWN TO THE SLAVE CYLINDER MELTED ACROSS THE EXHAUST MANIFOLD THEREBY RELEASING ALL THE HYDRAULIC FLUID, UPON SHIFTING OUT OF OVERDRIVE DUE TO THE TRAILER AND THE GRADE ON THE FREEWAY, THE CLUTCH PEDAL STAYED ON THE FLOORBOARD OF VEHICLE RESULTING IN VEHICLE EFFECTIVELY BEING STUCK IN NEUTRAL. *SLC