2001 Ford F-250 Tires & Wheels Problems

TAILPIPE IS CLOSE ENOUGH TO SPARE TIRE TO MELT TIRE. TIRE IS UNUSABLE. LATER VEHICLES HAVE A HEAT SHIELD IN PLACE TO PREVENT THIS. FORD SHOULD HAVE RECALLED EARLIER UNITS.

MY RECENTLY PURCHASED VEE RUBBER A/T TIRE BLEW UP WITH A LOUD BANG SUNDAY MORNING PARKED IN THE DRIVEWAY, THANKFULLY, AND NOT ON THE ROAD. I JUST BOUGHT FOUR TIRES FROM SIMPLE TIRE ON 07/07/2016 AND ONLY PUT 200 MILES ON THEM. IT APPEARS TO ME LIKE AN AIR LEAK DEVELOPED NEAR THE TREAD/SIDEWALL AREA AND DELAMINATED THE SIDEWALL FROM THE INNER LINER AND BLEW OUT NEAR THE BEAD. TIRES: VEE RUBBER TAIGA A/T LT285/75R-16 R 126/123R THE ONLY DATE CODE MARKING I SEE IS 0316?

The contact owns a 2001 Ford F-250 equipped with Toyo tires, Tire Line: HT Open Country, Tire Size: LT265/75/R16, DOT Number: CXLTCAK4815. The contact stated that while driving at an undisclosed speed, the vehicle was shaking and felt like the front tires were bouncing. The contact veered to the side of the road, where he noticed that the tires were deformed. The contact continued to drive. The vehicle was taken to the local dealer where it was diagnosed that the tread belt was separating. The front tires were replaced; however, the failure reoccurred with the rear tires. The vehicle was taken to an independent tire mechanic where the rear tires were replaced under an unknown recall. The contact stated that the failure reoccurred on the front tires. The dealer was notified of the failure. The manufacturer was notified of the failure but did not provide any assistance. The tires were not replaced. The tires were replacement equipment. The tire failure mileage was 30,000. The vehicle failure mileage was approximately 230,000.

WIFE WAS DRIVING EAST BOUND ON 580 COMING DOWN WHAT WE CALL THE ALTAMONT PASS ON A SUNDAY AFTERNOON WITH MODERATE TRAFFIC. THE VEHICLE WAS EMPTY SO THE BOUNCING ON THIS FREEWAY IS PRETTY STANDARD. SHE HEARD A LOAD EXPLOSION AND THE TRUCK BEGAN TO SHAKE. SHE IMMEDIATELY PULLED TO THE SHOULDER AND NOTICED THE DRIVER SIDE REAR TIRE WAS SHREDDED ALONG WITH THE SIDE OF THE TRUCK. PRAISE GOD SHE HAD JUST HAD THE TIRES ROTATED OTHERWISE THIS TIRE WOULD HAVE BEEN IN THE FRONT AND PULLED HER ACROSS TRAFFIC. HER SPEED WAS IN THE RANGE OF 55-65 MPH WHICH IS TYPICAL FOR HER AND ON THE FREEWAY THIS TIME OF DAY. CONDITIONS WERE CLEAR AND DRY.

WITHOUT WARNING, OUTER TIRE TREAD SEPARATED FROM TIRE WHILE DRIVING AT 65 MPH. UNIROYAL LIBERATOR, TIRE CODE BFOR C62U 2610, PURCHASED NEW ON 08/02/2010 WITH APPROXIMATELY 40,000 MILES. THIS HAPPENED ABOUT 0800, WEATHER WAS CLEAR, SUNNY AND ABOUT 50F DEGREES.

TIRE BLOWOUT WITH COMPLETE TREAD SEPARATION WHILE TRAVELING ON INTERSTATE PULLING A HORSE TRAILER. WAS ABLE TO SAFELY PULL TO SHOULDER & CHANGE TIRE FOR SPARE. TREAD DAMAGED TRUCK PANEL, TAILPIPE & BENT FRONT AXLE OF TRAILER. TIRES WERE WELL MAINTAINED AND HAD BEEN CHECKED BEFORE DEPARTURE. TIRES WERE NITTO TERRA GRAPPLER LT 285/75R16 126/123Q LOAD RANGE E. *TR

TL* THE CONTACT OWNS A 2001 FORD F-250 EQUIPPED WITH MICKEY THOMPSON/BAJA ATZ TIRES, TIRE SIZES 35 * 12.50 R20. THE CONTACT STATED THAT WHILE TRAVELING 70 MPH, THE RIGHT FRONT PASSENGER TIRE BLEW OUT AND CAUSED THE CONTACT TO RUN OFF THE SIDE OF THE ROAD. THE CONTACT WAS NOT INJURED. THE CONTACT STATED THE BELT SEPARATED FROM THE TIRE. THE VEHICLE WAS TOWED TO A REPAIR SHOP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA RECALL CAMPAIGN ID NUMBER:06T024000(TIRES:TREAD/BELT) THE FAILURE AND CURRENT MILEAGE WAS 2360,000. UPDATED 11/19/12 *BF THE CONSUMER STATED THE DISCOUNT TIRE MANAGER REFUSED TO REPLACE THE TIRE OR GIVE A DOCUMENT STATING THERE WAS NO FAILURE WITH THE TIRE. THE MANAGER DID BALANCE THE TIRE BUT WOULD NOT PRINT A RECEIPT FOR THE CUSTOMER. ON 10/15/2012 THE CONSUMER FILED A REPORT WITH COOPER TIRE OVER THE PHONE AND WAS TOLD A PACKAGE WOULD BE SENT OUT. ON 10/30/2012 3 TIRES WERE BALANCED VIBRATING RECURRED. UPDATED 11/20/2012 *JS

MY THIRD UNIROYAL LIBERATOR TIRE HAS FAILED IN THE SAME MANNER AS THE TWO BEFORE. THIS IS MY THIRD COMPLAINT CONCERNING THESE DEFECTIVE TIRES. THESE TIRES ALL FAILED IN THE SAME EXACT MANNER (TREAD/TIRE SEPARATION) AND ALL WITHIN WEEKS OR MONTHS OF EACH OTHER. THE TREAD PULLED LOOSE FROM THE CARCASS,CAUSING A BUMP-IMBALANCE. I RECOGNIZED THE FAILURE AND WAS ABLE TO DRIVE HOME WHERE I CHANGED TO A SPARE. I LATER REPLACED THIS TIRE. THIS TIRE ONLY HAVE ABOUT 37,000 MILES. WALMART,WHERE I PURCHASED THE TIRES,REFUSES TO GIVE ANY TYPE OF WARRANTY OR TIRE CREDIT AND NO LONGER CARRY THIS TIRE. THIS TIRE HAD PLENTY OF TREAD AND WAS WELL WITHIN ITS LIFE SPAN. THIS LIBERATOR TIRE SHOULD BE RECALLED AND PULLED OFF THE MARKET BECAUSE OF ITS CONSISTENT FAILURE RATE. I HAVE SENT COMPLAINTS TO UNIROYAL WITH NO RESPONSE. PLEASE HAVE A RECALL BEFORE SOMEONE GETS KILLED OR INJURED. THESE THINGS ARE JUNK. *TR

ON SEPTEMBER 12, 2011, A KUMHO ROAD VENTURE AT TIRE, SIZE LT235/85R16, DOT K2ORYD4A3508 (MANUFACTURED AT KUMHO?S BINH DUONG PLANT IN VIETNAM IN THE 35TH WEEK OF 2008) SUFFERED A CATASTROPHIC TREAD SEPARATION, RESULTING IN SEVERE INJURIES TO THE FRONT SEAT PASSENGER OF THE FORD F-250 AND THE DEATH OF HER SON, WHO WAS 32 WEEKS OLD AND STILL IN UTERO. A LAWSUIT HAS BEEN FILED AGAINST KUMHO TIRE CO., INC. AND KUMHO TIRE U.S.A., INC. IN THE UNITED STATES DISTRICT COURT FOR THE DISTRICT OF KANSAS (CASE NO. 2:13-CV-02393-JTM-TJJ). DURING THE DISCOVERY STAGE OF THE CASE, THE PASSENGER RETAINED TROY COTTLES, A RENOWNED TIRE FAILURE EXPERT. AFTER INSPECTING THE SUBJECT TIRE, MR. COTTLES FOUND THE FOLLOWING DEFECTS IN THE SUBJECT TIRE: (1) INADEQUATE BONDING BETWEEN BELTS (TRAPPED AIR/STEAM BLISTER IMPRESSIONS); (2) PREMATURE OXIDATION OF THE BELT SKIMS; (3) BELTING DEFECTS (COINCIDENTAL BELT ENDINGS, IRREGULAR BELT WIRE SPACING, GAPPED BELT SPLICES, DOG-EARED SPLICES, SNAKING, AND SPREAD CABLES); (4) CORD SHADOWS ON THE INNERLINER; (5) LOW TOP BELT WIDTH TO TREAD WIDTH RATIO; AND (6) INADEQUATE APPLICATION OF NYLON CAP PLIES. AS PART OF HIS WORK ON THE CASE, MR. COTTLES TESTED TWO EXEMPLAR KUMHO ROAD VENTURE AT TIRES OF THE SAME SIZE AS THE SUBJECT TIRE THAT WERE ALSO MANUFACTURED AT KUMHO?S VIETNAM PLANT. BOTH OF THOSE TIRES FAILED IN SIDEWALL FAILURE MODE IN APPROXIMATELY 10,000 MILES OR LESS UNDER PROPER LOADS, INFLATIONS, AND SPEEDS THAT WERE MONITORED DAILY. SEE ATTACHED TEST REPORTS AND PHOTOGRAPHS. THIS INFORMATION IS BEING SUBMITTED BY THE ATTORNEYS FOR THE INJURED PASSENGER, AND WITH HER PERMISSION, IN HOPES THAT THIS TIRE (AND THOSE SIMILAR TO IT) WILL BE INVESTIGATED AND RECALLED TO ENSURE NO ONE ELSE IS NEEDLESSLY INJURED OR KILLED AS A RESULT OF THESE DANGEROUS AND DEFECTIVE TIRES....UPDATED 07/30/15 *BF UPDATED 10/23/2017*CN

I HAD ANOTHER UNIROYAL LIBERATOR TIRE (265/75/16 E-RATED, LIGHT TRUCK TIRE) FAILURE. BOTH TIRES FAILED WITHIN ONE THOUSAND MILES OF EACH OTHER AND IN THE SAME EXACT WAY. I FILED A COMPLAINT WITH NHTSA ON THE FIRST TIRE APPROX. 2-MONTHS AGO. BOTH TIRES AT ABOUT 35 TO 36,000 MILES, WHILE DRIVING AT SPEEDS APPROACHING 65 MPH FORMED A BALLOON ON TOP OF THE TREAD CAUSING AN IMBALANCE. AFTER CHANGING THE TIRE, IT EXPLODED IN THE BED OF MY TRUCK. IT WAS OBVIOUS TO ME THAT A TREAD SEPARATION HAD OCCURRED. ONE COULD SEE THE SMOOTH AREAS WHERE THE TREAD HAD SEPARATED FROM THE BELT CARCASS VERSUS THE AREA WHERE THE TREAD PULLED AWAY WHEN IT EXPLODED. THESE UNIROYAL LIBERATORS SHOULD BE RECALLED BECAUSE OF HOW QUICKLY THIS FAILURE OCCURS. BOTH TIRES HAD PLENTY OF TREAD AND WERE RUN WITHIN THE PROPER PRESSURE RANGES (70 TO 80 PSI). I HAVE SENT UNIROYAL EMAIL COMPLAINTS CONCERNING THESE TIRES. I HAVE ONE REMAINING ON MY TRUCK THAT WILL BE REPLACED BECAUSE I KNOW IT WILL ALSO FAIL ANY MOMENT. PLEASE DO WHAT YOU CAN TO GET THESE TIRES OFF THE MARKET. THE TIRES DATE OF MANUFACTURE WAS 14TH WEEK OF 2007. *TR

CONCERNING TREAD SEPARATION ON UNIROYAL LIBERATOR A/T LT 265/75R16 TIRE PURCHASED FROM WALMART ON 092007,APPROX. 36,000 MILES ON TIRE. USED ON 2001 FORD F-250,DIESEL, REAR WHEEL DRIVE. THE TIRE HAS DOT MARKING AS FOLLOWS: DOT BFW8 C62U 0807, E RANGE RATED. ON MARCH 23 2011 WHILE DRIVING AT 65 MPH I FELT BAD VIBRATION AND WHEN SAFE, PULLED OFF ROADWAY TO FIND THE RIGHT REAR TIRE TO HAVE A BULGE ON TREAD AND SIDE WALL DISTORTION. I HAVE HAD THIS SAME FAILURE FROM COOPER TIRES WHICH CAUSED LOSS OF CONTROL AND DESTRUCTION TO QUARTER PANEL. I CHANGED THE TIRE AND LATER (03302011) CONTACTED UNIROYAL WHO OPENED A FILE BASED ON MY PHONE NUMBER([XXX]). UNIROYAL CLAIMS NO RECALL NOR DO THEY ACKNOWLEDGE ANY SIMILAR COMPLAINTS ON THIS TIRE. I HAVE 3 OF THESE TIRES AND HAVE SAFETY CONCERNS ON THE 2-REMAINING TIRES IN USE. AT TIMES I PULL AN RV OR A BOAT AND MUST HAVE AN ASSURANCE THAT THESE TIRES WILL BE SAFE TO USE. *TR INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

DRIVING MY TRUCK ON HIGHWAY. THE SPARE TIRE CABLE BROKE THE TIRE WENT UNDER A TRAILER AND BENT TWO RIMS AND THE AXLE. I BOUGHT THE TRUCK NEW HAS 60,900 MILES THE SPARE HAS NEVER BEEN OF THE TRUCK. *TR

I'VE HAD TWO OF THE TIRES GOING 65-70 MPH BASICALLY GO FLAT AND TEAR INTO PIECES AFTER ONLY A FEW SECONDS. BOTH TIMES THERE IS HARDLY NO IDENTIFYING PARTS OF THE TIRE LEFT ON THE RIM. THE LAST TIME I WAS HAULING A 20' TRAILER WHEN IT WENT FLAT AND TORE TO SHREDS. THE FIRST TIME I WAS DRIVING WITH NO TRAILER AND I HEARD IT GO FLAT THEN THE TIRE JUST TORE TO SHREDS ALSO. THESE TIRE ARE ONLY A YEAR OLD. IT DID BEND THE REAR QUARTER PANEL. A EMPLOYEE WAS BEHIND ME AND SAID BASICALLY THE WHOLE TIRE CAME OFF THE RIM AND WENT ACROSS THE MEDIAN OF THE INTERSTATE. *TR

TL*THE CONTACT OWNS A 2001 FORD F250 WITH B.F. GOODRICH ALL TERRAIN TIRES, SIZE 285/75R16. THE TREAD ON ALL FOUR TIRES WAS BREAKING APART IN HUGE PIECES WHILE SHE WAS DRIVING. THE TIRE MILEAGE WAS 20,000 ON EACH TIRES. THE FAILURE MILEAGE WAS 15,000. UPDATED 09/14/09 *BF UPDATED 09/15/09.*JB

INVOLVED IN A SINGLE VEHICLE ROLLOVER, CAUSED BY TIRE TREAD SEPARATION ACCORDING TO STATE POLICE, TIRE TREAD CAME OF, TIRE STILL HAS AIR IN IT, VEHICLE IS TOTALED, FOUND PIECE THAT CAME OFF TIRE IS A (GENERAL AMERITRAC TR LT235/85R16) SUSTAINED MAJOR INJURIES DUE TO ROLLOVER. *TR

I WAS DRIVING ON A 2-LANE STATE HIGHWAY AT APPROXIMATELY 65MPH. MY PICKUP IS A 2001 FORD SUPERDUTY DIESEL SUPERCAB 4X4. THE WEATHER WAS OVERCAST, TEMPERATURE ABOUT 75 DEGREES. I WAS PULLING AN 18' FLATBED "CAR HAULER" TYPE TRAILER, TOTAL WEIGHT (TRAILER & LOAD) APPROXIMATELY 1,000LBS. I HAD DRIVEN 60 MILES WITH NO INDICATION OF VIBRATION OR PROBLEMS. I STOPPED FOR AN HOUR THEN RESUMED DRIVING. I NOTICED SOME VIBRATION, SO STOPPED AND CHECKED BOTH PICKUP AND TRAILER TIRES. INFLATION WAS GOOD AND THERE WERE NO INDICATIONS OF PROBLEMS WITH ANY TIRES. I CONTINUED MY TRIP. WITHIN THE NEXT 5 MILES THE TREAD SEPARATED FROM THE LEFT FRONT (DRIVERS SIDE) TIRE ON MY PICKUP. THE PICKUP IMMEDIATELY LURCHED TO THE LEFT ACROSS THE CENTERLINE. I REGAINED CONTROL AND WAS ABLE TO PULL OFF THE SHOULDER WITHOUT FURTHER INCIDENT. THE TREAD SEPARATION DAMAGED THE FENDER, RUNNING BOARD, INNER FENDER, INSULATION LINER, AND FRONT BUMPER. THERE WERE NO PERSONS INJURED. I WAS ABLE TO "TIE-WRAP" THE INNER FENDER PANEL BACK IN PLACE AND INSTALL THE SPARE TIRE TO CONTINUE THE TRIP. *TR

I WAS DRIVING MY 2001 F250 FORD TRUCK AND PULLING A TRAILER. I WAS TRAVELING AT A SPEED OF 60 MPH ON A TWO- LANE HWY. I HAD JUST CHECKED ALL THE TIRES FOR CORRECT AIR PRESSURE BEFORE LEAVING HOME SINCE I WAS TAKING A LOAD OF PIGS TO MARKET. WITHOUT WARNING, SUDDENLY I WAS IN AN UNCONTROLLABLE JERK LEFT INTO THE ONCOMING LANE. FORTUNATELY, I WAS ABLE TO GAIN CONTROL JUST IN TIME TO AVOID A HEAD-ON COLLISION AS MY TRUCK WENT INTO THE DITCH AND STOPPED. THE COMPLETE OUTER LAYER OF RUBBER CAME OFF MY LEFT FRONT TIRE AND WRAPPED ITSELF AROUND THE INSIDE DISC BRAKE/AXLE ASSEMBLY AND TORE OFF ALL OF THE BRAKE LINES FROM THEIR MOORING LEADING TO THE LEFT FRONT BRAKE. (I ONLY HAVE 23,400 MILES ON THIS TRUCK AND HAVE HAD NO OTHER TIRE INCIDENTS). I HAD TO REMOVE THE TIRE WHICH STAYED INFLATED MINUS ITS COMPLETE OUTER SHELL IN ORDER TO ENTANGLE AND REMOVE THE OUTER SHELL PORTION OF THE TIRE FROM THE BRAKE/AXLE ASSEMBLY. THE MAIN STEEL BRAKE LINE WAS NOT BROKEN AS WERE OTHER RUBBER LINES TO THE BRAKE ASSY. I AM AWAITING AN EVALUATION FROM FORD ON THE FRONT LEFT WHEEL ALIGNMENT AND BRAKE ASSEMBLY/LINES CONDITION. FORD HAD NO RECALL ON THE TIRES AND AT FIRST FIRESTONE SERVICE MANAGER PROMISED TO REPLACE ALL OF MY TIRES FREE OF CHARGE BECAUSE THERE WAS A RECALL ON THAT FIRESTONE TIRE. THE NEXT DAY, ONCE THEY REPLACED THE TIRES THEY CAME IN AND ADVISED ME THAT THE RECALL DID NOT MATCH THE SERIAL NUMBER ON MY TIRES AND TOLD ME THEN THAT I WOULD HAVE TO PAY FOR THE REPLACEMENT. TO COMPENSATE ME FOR THEIR MISTAKE ON THE RECALL THEY TOLD ME THAT THEY WOULD NOT CHARGE ME FOR THE LABOR PORTION OF THE REPLACEMENT IF I WOULD PAY FOR THE TIRES. I WAS NOT ABOUT TO DRIVE ON THE REMOVED TIRES AGAIN AND WAS BETWEEN A ROCK AND A HARD PLACE, SO I PAID THE BILL. WHILE CASH LAYOUT IS AN ISSUE HERE THE REAL ISSUE IS POOR TIRE PERFORMANCE THAT CAME WITHIN A HEARTBEAT OF KILLING ME AND MANY OTHER INNOCENT PEOPLE. *TR

NONE AT THIS TIME. *YT

FIRESTONE STEELTEX A/T M/S, LT265/75 R16 123/1200 LOAD RANGE E, TIRE EXPLODED ON HIGH WAY. THE TREAD CAME OFF THE TIRE. THIS HAPPENS ON RETREADS BUT SHOULD NOT HAPPEN ON THE ORIGINAL TIRES. THE TIRE DID NOT DEFLATE IMMEDIATELY BUT THERE WAS CONSIDERABLE DAMAGE TO THE TRUCK. THE TIRES ARE ON A 2001 FORD 250. ORIGINAL TIRES WITH 64000 MILE. TREAD DEPTH WAS RECENTLY CHECKED AND WERE WELL WITHIN STANDARDS. *TR *UPDATED 12/12/07 *BF UPDATED 12/12/07

TL*THE CONTACT OWNS A 2001 FORD F250. WHILE DRIVING APPROXIMATELY 60 MPH IN DRY CONDITIONS, THE REAR PASSENGER SIDE TIRE BLEW OUT. BEFORE THE BLOW OUT, THE CONTACT HEARD A NOISE FOLLOWED BY A LOUD BOOM. HE THEN NOTICED THAT THE TREAD HAD SEPARATED FROM THE TIRE BEFORE IT FLATTENED. THE CONTACT WAS ABLE TO PULL OFF THE ROAD BEFORE A CRASH OCCURRED. THE TIRE WAS A CONTINENTAL GENERAL LT 265/75R16 TIRE, WHICH IS NOT THE STANDARD ISSUE TIRE FOR HIS VEHICLE. THE TIRE WAS ALSO UNAVAILABLE IN THE DROP DOWN MENU AT THE TIME OF THIS COMPLAINT. THE CONTACT CALLED THE MANUFACTURER AND SENT THEM THE FAILED TIRE. THE MANUFACTURER STATED THAT HE MUST HAVE STRUCK SOMETHING IN THE ROAD TO CAUSE THE FAILURE. THE CONTACT HAS PICTURES OF THE FAILURE AND THE MANUFACTURER IS RETURNING THE TIRE. THE CURRENT MILEAGE IS 118,000 AND FAILURE MILEAGE WAS 117,000.