2005 Ford F-350 Electrical System Problems

Vehicle stalls while driving and wont start again suddenly while operating. Fuel injectors won’t feed fuel line to restart or operate. Occasional start but then stalls continuously until battery dies from trying. Will start when priming the carburetor however will not stay running and stalls out.

The all very common issues with the year f350 and the 6.0 l. Engines, are as such. The malfunctioning FICM. THE high and low oil coolers, the inter coolers and head studs. Also leaking break fluid .

[XXX], [XXX] approx age 40 lives and works at [XXX].[XXX] can also control the computers to cancel out and delete the use of catalytic converters, delete the use of DEF intake, delete the use of DPF particulate filters, and not react to controls such as manual braking or acceleration because the computer is controlling when and not the driver. [XXX] strictly states that he cannot have any emissions controls such as EGR, DEF, DPF, catalyst, or any pollutant controls. [XXX] intentionally set it up to have flaws and be dangerous for one reason: to get the customer to keep returning again and again with vehicle problems, wiring electrical problems, performance problems, overheating problems, and never ending engine problems not to mention transmission problems because the transmission could not handle the increased output of the engine. The hydroboost and ABS module and master cylinder that controls the brakes can be easily rigged so that when the driver stomps on the brakes, there is no braking action whatsoever for a 3-5 second delay before skidding the tires and locking the brakes. [XXX] altered the hydroboost and ABS module and master cylinder and the electronic controls to the braking system. [XXX] [XXX] partner admitted the hydrobooster and master cylinder was the problem because he admitted what [XXX] did as sabotage to the customer’s truck. [XXX] deletes the DPF and DEF and the electronics rewiring the truck. [XXX] has a pattern of keeping customers vehicles for excessively long periods of time: 42 days to change batteries, change fuel pump change PCM fusebox and rewire truck. [XXX] has removed the all the catalytic converters and he has removed all the EGR and emissions pollutant controls on [XXX]. [XXX] has sabotaged this truck’s braking system, electrical systems, fuse box wiring, electronic braking wiring, accelerator electronic control. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

WHILE DRIVING DOWN THE HIGHWAY(45-55MPH) VEHICLE DASH LIGHTS, RADIO, WINDOWS ALL STOP WORKING. THEY COME BACK ON RANDOMLY. NO CHANGE TO LITTLE CHANGE WHEN RE-STARTING. VEHICLE ALSO LOSES POWER AND THE ENGINE SEEMS TO PAUSE AND GO, OVER AND OVER LIKE IT'S STRUGGLING. I'VE TAKEN IT TO SEVERAL FORD CERTIFIED MECHANICS WHO ARE BAFFLED.

TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE SUDDENLY STALLED. AFTER, RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (MATTHEWS FORD, 1101 WEST SW. EXPRESS DR., BROKEN ARROW, OK) WHERE IT WAS DIAGNOSED THAT THE ELECTRICAL WIRE HARNESS WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM), ALTHOUGH IT EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 45,000. *TT *JS

THE INSTRUMENT CLUSTER AND RADIO CUT OUT FREQUENTLY WHILE THE VEHICLE IS RUNNING. THIS CAUSES THE SPEEDOMETER, TACHOMETER, FUEL GAUGE, THERMOSTATS, AND ODOMETER TO SHOW THERE IS NO POWER TO THEM AND THE NEEDLES RESTS AS THEY DO WHEN THE VEHICLE IS OFF. THE RADIO ALSO CUTS OUT DURING THIS TIME. THIS HAPPENS WHEN THE VEHICLE IS STATIONARY, MOVING, ON CITY STREETS, AND ON HIGHWAYS. THERE IS NO WARNING WHEN THIS HAPPENS. IT WILL STAY OFF FOR SECONDS TO MINUTES. CURRENTLY THERE IS NO RECALL FROM FORD. THERE IS INFORMATION ON THE INTERNET CONCERNING OTHERS WITH THE SAME PROBLEM SO THIS IS NOT A SINGLE VEHICLE ISSUE. I AM CURRENTLY UNABLE TO GET A STATE VEHICLE SAFETY INSPECTION DUE TO THE INSTRUMENTS NOT FUNCTIONING PROPERLY.

TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STALLED WITHOUT WARNING AND FAILED TO RESTART. THE CONTACT HAD THE VEHICLE TOWED. THE VEHICLE WAS NOT TAKEN TO THE DEALER NOR WAS IT DIAGNOSED AND REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT TO FILE A COMPLAINT IN AN ATTEMPT TO HAVE THE VEHICLE INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 123,000.

VEHICLE STALL/DIE WHILE DRIVING WITHOUT ANY WARNING. WHEN THE VEHICLE DIES, UNABLE TO TURN THE STEERING WHEEL AND NO POWER AT ALL. HAVE A RECALL NUMBER 05S34, BUT FORD DEALERSHIP WON'T REPAIR IT BECAUSE MY VIN ISN'T ON RECALL. WHAT SHOULD I DO NEXT?

AUG 1, 2014 FUEL INJECTION FAILURE, DUE TO FUEL INJECTION WIRE HARNESS CHAFING. SEPT 15 FUEL INJECTION FAILURE DUE TO FICM FAILURE RESULTING IN SEVERE LOSS OF POWER. VEHICLE BARELY MOVES, STRONG POSSIBILITY OF CRASH DUE TO VEHICLES UNEXPECTED SUDDEN LOSS OF POWER AND INABILITY TO MOVE. INCIDENTS CLOSELY RELATE TO RECALL 05V270000 FOR VEHICLE MANUFACTURED CLOSE TO SAME DATES. BELIEVE THAT RECALL SHOULD BE REOPENED AND EXTENDED TO INCLUDE ALL 6.0 DIESEL ENGINES. *TR

TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE ATTEMPTING TO START THE VEHICLE, IT FAILED TO START. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL INJECTION CONTROL MODULE, SENSOR, AND TURBO HOSES FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. A DEALER WAS NOT CONTACTED. ALSO, WHILE DRIVING 30 MPH, THE ENGINE BEGAN TO REV AND THE CONTACT HAD TO BRAKE TO STOP THE VEHICLE FROM SURGING FORWARD AND COLLIDING WITH THE PRECEDING VEHICLE. THE VEHICLE CONTINUED TO SURGE AS THE CONTACT DROVE. THE CONTACT PULLED OVER AND TURNED OFF THE VEHICLE. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE INJECTION CONTROL PRESSURE SENSOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF BOTH FAILURES AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT WHEN DRIVING AT HIGHWAY SPEEDS, THE VEHICLE STALLED. THE CONTACT MENTIONED THAT THE VEHICLE FAILED TO RESTART AFTER STALLING. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO WAS UNABLE TO REPLICATE THE FAILURE. THE CONTACT WAS MADE AWARE ABOUT NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM), HOWEVER DID NOT VERIFY WITH THE MANUFACTURER IF THE VEHICLE WAS INCLUDED. THE FAILURE MILEAGE WAS 137,000.

TL* THE CONTACT OWNS A 2005 FORD F-350SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND RESUMED NORMALLY. THE FAILURE RECURRED AND THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V27000 (ELECTRICAL SYSTEM) HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 137,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. AFTER SEVERAL ATTEMPTS THE CONTACT WAS ABLE TO START THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THE FUEL INJECTION CONTROL MODULE WOULD HAVE TO BE REPLACED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM) HOWEVER, THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 97,300.

TL* THE CONTACT OWNS A 2005 FORD F-350SD. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING AND COULD NOT BE RESTARTED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE FUEL INJECTOR CONTROL MODULE NEEDED TO BE REPLACED. THE CONTACT WAS ALSO ADVISED THAT THE VEHICLE WAS NOT INCLUDED NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE AND CURRENT MILEAGES WAS 212,000. *TR

TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE LUNGED FORWARD AND STALLED. THIS FAILURE OCCURRED ON MORE THAN ONE OCCASION. THE CONTACT STATED THAT THE VEHICLE WOULD NOT ALWAYS RESTART. THE CONTACT FOUND NHTSA RECALL CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM) BUT THE MANUFACTURER STATED THE VEHICLE WAS NOT INCLUDED. THE DEALER TOLD THE CONTACT THEY WERE NOT SURE OF WHAT CAUSED THE FAILURE. THE FAILURE MILEAGE AND CURRENT MILEAGES WAS 70,000. *TR

MY HUSBAND WAS DRIVING THE TRUCK AFTER SEVERAL REPAIRS AND TURNED ONTO THE HIGHWAY AND THE TRUCK ELECTRICAL SYSTEM JUST SHUT DOWN! WE CONTACTED THE DEALERSHIP THEY DIDN'T HELP WE HAVE PUT OUR OWN MONEY IN THIS TRUCK TO FIX IT AND WAS TOLD THIS TRUCK SHOULDN'T HAVE BEEN SOLD TO US THAT IT WAS A LEMON PER THE MASTER MECHANIC! I DON'T KNOW WHAT TO DO THIS TRUCK IS A HAZARD TO DRIVE AND WHEN I SPOKE WITH THE DEALERSHIPS OWNER HE TOLD ME TO BRING IT BACK AND THEY WILL SELL IT IN THE AUCTION AGAIN. ITS A DANGER AND CAN'T BE FIXED I HAVE ALL REPORTS ON WHAT WAS DONE ON THIS TRUCK. *TR

TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE, STATING THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 170,000 AND THE CURRENT MILEAGE WAS 180,000. *TR

TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT WHILE TRAVELING 30 MPH, THE VEHICLE STALLED WITHOUT ANY WARNINGS. THE VEHICLE RESTARTED IMMEDIATELY AFTER THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM: WIRING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 160,000 AND THE CURRENT MILEAGE WAS 166,000.

TL* THE CONTACT OWNS A 2005 FORD F-350 SUPER DUTY. THE CONTACT STATED THAT AFTER REFUELING, THE VEHICLE WOULD NOT RESTART. THE CONTACT HAD TO APPLY STARTING FLUID IN ORDER TO START THE VEHICLE. THE FAILURE WAS EXPERIENCED APPROXIMATELY THREE TIMES. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM: WIRING) BUT DID NOT CONFIRM WITH THE MANUFACTURER IF THE VEHICLE WAS INCLUDED IN THE RECALL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRICAL SYSTEM WIRING HAD MALFUNCTIONED. THE VEHICLE WAS REPAIRED WITH A NEW WIRING HARNESS. THE FAILURE AND THE CURRENT MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2005 FORD F350 SD. WHILE DRIVING IN REVERSE AT 2 MPH, THE CONTACT STATED THAT THE VEHICLE SUDDENLY STALLED WITHOUT WARNING. HE REFERENCED THE SIMILARITY TO NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM:WIRING). THE VEHICLE WAS TOWED TO A LOCAL DEALER WHO INSPECTED THE VEHICLE, AND INFORMED THE CONTACT THAT THE FUEL INJECTOR CONTROL MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 33,000.