2005 Ford F-350 Suspension Problems

[XXX] who performs automotive work out of his residence [XXX] and [XXX] of [XXX] have worked on this vehicle to spite the customer and to gouge the customer in unnecessary fraudulent repairs. They have deliberately set this vehicle up to fail with the braking system, the 6.0 engine being rebuilt to no avail, and constant driving problems such as pulling to the right and the left when brakes applied, constant overheating, constant oil temperature overheating, shuttering at highway speed, transmission failure, air conditioning failure, coolant system failure, electrical system failure, and every system that they have repaired, continues to fail. They specifically performed work on the electrical wiring and truck keeps blowing fuses. They performed work on the transmission and the transmission failed shortly after. They performed work on the engine and deleted illegally all the emissions EGR pollutant controls. They installed faulty wiring for the electric trailer brake controls and the electronic speed controls. They tampered with the air conditioning system causing the compressor to blow out, send metal through the a/c lines, and the belt stopped turning causing the serpentine belt to break, tear the fan shroud apart and shred. They also installed a trailer brake controller that was aftermarket and it caused brake loss and intermittent failure with the service brake system and speed control. Domingo also tuned the computer to make the truck output 550 horsepower which caused the new engine to fail prematurely and the transmission to fail as well. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

TL* THE CONTACT OWNS A 2005 FORD F-350. WHILE DRIVING OVER A BUMP IN THE ROAD, THE VEHICLE EXPERIENCED THE DEATH WOBBLE. THE FRONT END OF THE VEHICLE SHOOK UNCONTROLLABLY AND WOULD NOT STOP. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO MOUNTAIN VIEW FORD (301 E 20TH ST, CHATTANOOGA, TN 37408, (423) 756-1331) WHERE IT WAS DIAGNOSED THAT A NEW TRACK BAR WAS NEEDED. THE VEHICLE WAS THEN TAKEN TO MARSHALL MIZE FORD (5348 TN-153, HIXSON, TN 37343, (423) 875-2023) WHERE IT WAS DIAGNOSED THAT THE VEHICLE NEEDED A TRACK BAR. THE VEHICLE WAS REPAIRED; HOWEVER, THE REPAIR FAILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 36,000.

TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE VIOLENTLY SHOOK. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THE VEHICLE HAD A FRONT END OSCILLATION AND THAT TRACK BAR, STABILIZER LINK, AND UPPER AND LOWER BALL JOINTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 127,000.

2005 FORD F350 CREWCAB. I TOOK IT TO THE DEALER BECAUSE A FEW PEOPLE TOLD ME THAT WHEN THEY WERE FOLLOWING ME MY TRUCK WAS MAKING DOG TRACKS. IT WAS GOING DOWN THE ROAD CROOKED. I TOOK IT TO THE DEALER AND THEY FOUND I HAD A BROKEN LEAF SPRING IN THE RIGHT REAR OF MY TRUCK. I HAVE NOT MISUSED THIS TRUCK AND CONCERNED ABOUT THE QUALITY AND SAFETY. I JUST WANTED TO REPORT THIS. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

MY 2005 SD F-350 CREW CAB FORD TRUCK SHIMMIES VIOLENTLY WHEN TRAVELING ON THE INTERSTATE AND I HIT SOME UNEVEN ROADWAY. IT DOESN'T STOP UNTIL I ALMOST COME TO A STOP OR SLOW DOWN TO BELOW 45MPH. THE SHIMMY IS VERY UNCONTROLLABLE AND DANGEROUS AND SOMETIME THE TRUCK CHANGES LINES DO TO THE VIOLENT SHAKING. *TR

2005 F350 DIESEL DUALLY THIS VEHICLE NEEDS TO BE RECALLED! THE LETTER THAT FORD SENT TO OWNERS IS NOT ACCURATE! IT IS NOT THE TIRE PRESSURE OF THE VEHICLE CAUSING THE SEVERE SHAKE! MY WHOLE TRUCK SHOOK PROFUSELY! IT WAS QUITE SCARY. AT POSTED HIGHWAY SPEED LIMITS IF THERE IS A SLIGHT BUMP IN ROAD YOU CAN BE SLOWING DOWN AN HIT A BUMP AND TRUCK BEGINS TO SHAKE OR GOING A AROUND A CURVE ON THE HIGHWAY AT 65MPH AND IF THERE IS A BUMP IN THE ROAD ON THE CURVE THE ENTIRE TRUCK SHAKES PROFUSELY. RECEIVED A LETTER FROM FORD STATING IT WAS TIRE PRESSURE BUT MY TIRE PRESSURE IS PERFECT. THIS IS A DEFECT THAT NEEDS TO BE RECALLED IMMEDIATELY STEERING BOX ROCKER ARM TIRE ROD SOMETHING BUT THIS TRUCK IS NOT RIGHT. I HAUL A 40FT TRAILER AND IF I HAD BEEN HAULING IT I WOULD BE DEAD ALONG WITH SEVERAL OTHER CARS I WOULD WIPED OUT PLEASE GET THIS VEHICLE RECALLED FOR SAFETY OF THE CONSUMER IT IS DEFINITELY NOT THE PROBLEM THAT FORD CLAIMS AT THIS POINT. MY TRUCK NEEDS TO BE REPAIRED AT THE COST OF FORD AND THIS DEFECT NEEDS TO BE RECALLED! PLEASE TAKE THIS COMPLAINT SERIOUSLY. SOMEONE WILL BE KILLED LIKE THIS. *TR

I OWN A 2005 FORD F 350 THAT SOMETIMES HAS A VIOLENT STEERINGWHEEL SHAKE AT HIGHWAY SPEEDS AFTER HITTING SMALL BUMPS IN ROADWAY. HAS HAPPENED MAYBE 5 TIMES IN 4YEARS WHERE SO SEVERE THAT COULD NOT TURN STEERING WHEEL UNTIL SPEED WAS REDUCED BY BRAKING QUICKLY. *TR

I OWN A 2005 FORD F-350 4X4 6.0 DIESEL. IT HAS 63,000 MILES ON IT. ON MANY OCCASIONS THE STEERING WHEEL HAS SHIMMIED OR OSCILLATED VIOLENTLY TO THE POINT I ALMOST LOST CONTROL OF THE TRUCK. THIS IS VERY DANGEROUS. WHEN THE FRONT WHEELS HIT A BUMP OR POTHOLE, WITH A VERY SMALL AMOUNT OF TURNING THE VEHICLE TO THE LEFT OR RIGHT SUCH AS GOING AROUND A CURVE, THE FRONT WHEELS HAVE STARTED TO VIOLENTLY SHIMMY OR OSCILLATE CAUSING THE STEERING WHEEL TO VIOLENTLY SHIMMY BACK AND FORTH. THIS USUALLY OCCURS AT SPEEDS ABOVE 40 MPH. FOUR TIMES I HAVE ALMOST LOST CONTROL OF THE TRUCK. ONCE THE TRUCK TURNED LEFT INTO AN ONCOMING LANE BUT FORTUNATELY THERE WHERE NO ONCOMING VEHICLES AT THAT MOMENT. I HAD TO SLOW DOWN TO ABOUT 25-30 MPH AND MOVE TO THE SHOULDER OF THE ROAD TO GAIN CONTROL OF THE VEHICLE. THIS IS A SERIOUS PROBLEM WITH THIS VEHICLE ESPECIALLY IN HEAVY TRAFFIC OR ON TWO LANE MOUNTAIN ROADS. I ORIGINALLY COMPLAINED ABOUT THIS AFTER I PURCHASED THE VEHICLE IN FEBRUARY 2005, AND WAS TOLD THE TRUCK WAS WITHIN SPECS AND THERE WAS NOTHING TO BE DONE. I REQUEST THE NHTSA LOOK INTO THIS. I HAVE DISCUSSED THIS WITH OTHER OWNERS AND THEY TOO HAVE HAD SIMILAR LOSS OF CONTROL PROBLEMS FROM STEERING WHEEL SHIMMY OR OSCILLATION. I BELIEVE THERE ARE OTHER TRUCKS THAT HAVE THE SAME PROBLEM. *TR

THIS PROBLEM IS NOT ISOLATED TO A PARTICULAR DAY OR A PARTICULAR INCIDENT; IT IS A CHRONIC PROBLEM THAT HAPPENS WHEN MY VEHICLE HITS A HOLE IN THE PAVEMENT OR A HARD BUMP WHEN TRAVELING AT 50 MPH OR MORE. MY VEHICLE IS A 2005 FORD F350 4X4 AND THE FRONT END BEGINS TO SHAKE VIOLENTLY AND IN MY OPINION COULD CAUSE A HEAD ON COLLISION. I HAVE SPOKEN TO THE FORD DEALERSHIP AND THEY SAID THERE IS NO RECALL FOR THIS PROBLEM. THEY OFFERED TO INSTALL A HEAVIER DUTY STEERING STABILIZER, WHICH WOULD COST ME 380.00, WHICH THEY SAY USUALLY HELPS THIS PROBLEM. THIS IS OBVIOUSLY A DESIGN FLAW BY FORD, AND THEY ARE DRAGGING THEIR FEET BECAUSE THEY DON'T WANT TO ADMIT THE PROBLEM OR PAY FOR THEIR MISTAKE. SOMEONE WILL SURELY BE KILLED, DUE TO THIS PROBLEM, AND THE GOVERNMENT NEEDS TO TAKE STEPS TO MAKE SURE THESE TRUCKS ARE FIXED BY FORD AT FORD'S EXPENSE. THIS IS NOT JUST A PROBLEM FOR MY TRUCK, BUT IS APPARENTLY AN EPIDEMIC. SOMEONE NEEDS TO DO THEIR JOB AND SEE THAT THIS IS CORRECTED. *TR

MAJOR FRONT END SHIMMY OR OSCILLATION RESULTING IN TOTAL LOSS OF STEERING AND BRAKING. NEAR CRASH ON SEVERAL OCCASIONS. HAS BEEN CHECKED BY DEALER AND PRIVATE MECHANIC. FORD SAYS IT IS TIRE PRESSURE OR BALANCE MECHANIC SAYS TIRES ARE BALANCED AND INFLATED CORRECT. UNKNOWN WHY THIS HAPPENS? HAS HAPPENED MANY TIMES SINCE NEW AND CHECKED AS MANY TIMES. COST ALOT OF MONEY TO KEEP CHECKING. *TR

1. IF I DRIVE OVER A BUMP IN THE ROAD AT 50MPH OR FASTER. 2. FRONT END SHIMMY. THE FRONT OF MY TRUCK SHAKES VIOLENTLY AND THE BRAKES HARDLY WORK TO GET THE TRUCK SLOWED DOWN. THE SHAKING IS SO VIOLENT THAT I LOSE CONTROL OF THE TRUCK. IT HAS SHAKEN MY TRUCK SO VIOLENTLY THAT IT HAS DAMAGED MY TRUCK. I HAVE HAD IT HAPPEN ABOUT 12 - 15 TIMES. I CAN'T DRIVE OVER 50MPH OR IT STILL HAPPENS. I HAVE ALMOST CAUSED 3 ACCIDENTS AS A RESULT OF THIS HAPPENING. IT HAPPENED ONCE WITH MY WIFE DRIVING WITH OUR KIDS AND SHE WENT OVER THE CENTERLINE AND ALMOST HIT A SEMI HEAD ON. 3. I HAVE TAKEN THE TRUCK TO THE DEALERSHIP TO GET REPAIRED AND THEY TELL ME NOTHING IS WRONG WITH MY TRUCK. I PURCHASED THE TRUCK NEW IN 2005 AND IT FIRST STARTED HAPPENING AT 10,000 MILES. TRUCK CURRENTLY HAS 34,000 MILES AND THE PROBLEM IS STILL HAPPENING. I CALLED FORD CUSTOMER CARE TODAY BECAUSE I RECEIVED A LETTER FROM THEM ABOUT THE PROBLEM. THEY TOLD ME THAT THEY DOCUMENTED THE PROBLEM, BUT BECAUSE THE TRUCK IS OUT OF WARRANTY I WOULD HAVE TO PAY FOR IT TO BE FIXED. IT SHOULD BE NOTED THAT I STARTED TAKING MY TRUCK INTO THE FORD DEALERSHIP BACK IN 2006 TO HAVE THIS PROBLEM ADDRESSED. I HAVE ASKED FORD TO LOOK INTO THIS PROBLEM MAYBE 4 OR 5 TIMES BEFORE I GOT THIS LETTER. I ALSO DID A GOOGLE SEARCH TODAY ABOUT THIS PROBLEM AND YOU CAN SEE THAT MANY PEOPLE POST ONLINE ABOUT THIS VERY PROBLEM. HOPE THIS BECOMES A RECALL SO I CAN KEEP ME AND MY FAMILY SAFE. THANK YOU. *TR

2005 FORD F-350 4X4 DUALLY WITH SEVERE FRONT END SHAKE AT AROUND 50 MPH AND HITTING A BUMP IN ROAD. MUST SLOW TO 35 MPH TO STOP SHAKING. FORD DEALER STATED PROBLEM WAS DUE TO IMPROPER TIRE PRESSURE. HAVE REPLACED STEERING STABILIZER, AND DRAG LINE, TO NO BENEFIT AS OF YET. *TR

OCCASIONALLY, AT INTERSTATE SPEEDS ONLY (65 - 75 MPH), FRONT END SHAKES VIOLENTLY WHEN CROSSING OVER A SMALL CHANGE IN SURFACE ELEVATION. (FOR EXAMPLE: TRANSITION FROM ROAD SURFACE TO BRIDGE SURFACE) IT IS NOT PREDICTABLE. VEHICLE STEERING IS COMPROMISED AND THE ONLY WAY TO REGAIN PROPER CONTROL IS TO ALLOW THE TRUCK TO SLOW TO APPROXIMATELY 50 MPH WHEN VIOLENT SHAKING WILL SUBSIDE. VEHICLE HAS BEEN INSPECTED BY ONE INDEPENDENT SHOP AND ONE FORD DEALERSHIP (WHERE VEHICLE WAS PURCHASED). NEITHER COULD IDENTIFY THE SOURCE OF THE PROBLEM. TRUCK IS STOCK WITH NO MODIFICATIONS. MOST RECENT EVENTS OCCURRED TWO CONSECUTIVE DAYS TRAVELING INTERSTATE 65 BETWEEN NASHVILLE AND SOUTHERN KENTUCKY. TWO DIFFERENT LOCATIONS, ONE NORTHBOUND AND ONE SOUTHBOUND. *TR

2005 FORD F350 PICK UP TRUCK SHAKES VIOLENTLY IN THE FRONT END AT SPEEDS EXCEEDING 55 MPH AFTER CROSSING OVER UNEVEN SURFACE. HAS HAPPENED OVER 25 TIMES AND IS VERY DANGEROUS. WILL ONLY STOP "WOBBLING" WHEN IT GETS BELOW APPROX. 30-25 MPH. I'VE HAD MANY INSTANCES WHERE I HAD TO GET THE TRUCK TO THE SHOULDER TO PREVENT BEING HIT FROM BEHIND OR SIDE SWIPED AND STILL GET THE TRUCK DOWN TO 25 MPH TO GET IT TO QUIT. STARTED SEVERAL MONTHS AGO, FOUND ONLINE THAT IT IS NOT TOO UNCOMMON AND NEVER KNEW WHERE TO GO UNTIL NOW. I AM SCARED TO DRIVE THIS TRUCK, HOWEVER, IT IS MY ONLY MEANS OF TRANSPORTATION TO WORK ETC. THE TRUCK HAS BEEN TO THE SHOP, $900 LATER AND TRUCK "SHOOK" THAT EVENING ON HIGHWAY 101. THE FORD STORE WHERE I PURCHASED IT SAID IT REALLY ISN'T FIXABLE.... WHATEVER THAT MEANS! *TR

ODOMETER 23400 WHEN DRIVING ON ROUGH ROAD, CROSSING RR TRACKS, ECT. VEHICLE FRONT END SLAMS UPPER STOP TO LOWER STOPS VIOLENTLY. YOU MUST SLOW TO APX.30-40 MPH. TO REGAIN CONTROL. THERE IS NO LOSS OF STEERING CONTROL, OR BRAKING JUST A VIOLENT "HOPPING OF FRONT WHEELS" . THE VEHICLE SHAKES WILDLY. *TR

FRONT END SHAKE VIOLENTLY WHEN A POT HOLE OR SETTLED TRENCH IN THE ROAD IS HIT. IT DOESN'T EVEN HAVE TO BE A DEEP OR LARGE POT HOLE. I HAVE TAKEN MY TRUCK INTO THE SHOP AND THE TECH SAID THE FRONT END COMPONENTS LOOK GOOD (TIE-ROD ENDS ECT...). I HAVE CHANGED THE SHOCKS AND STEERING DAMPER AND IT DID NOT HELP. *TR

2005 FORD F-350 DEVELOPS SEVER VIBRATION AND THE OSCILLATION OF THE STEERING WHEEL CAUSES SEVERE STEERING DIFFICULTY. THIS PROBLEM DOES NOT DISSIPATE UNTIL SPEED IS REDUCED TO APPROXIMATELY 40 MPH. OBVIOUSLY THIS IS VERY DANGEROUS ON A FAST MOVING FREEWAY WHERE SPEEDS CAN EXCEED 70 MPH. THE CONDITION IS ADDRESSED IN LITERATURE PROGRAM 09L02 LETTER DATED NOVEMBER 2011. THE VEHICLE HAS BEEN CHECKED AFTER AN EVENT AND THE TECHNICIAN HAS NEVER DISCOVERED A DEFICIENCY THAT HE CAN ATTRIBUTE TO THIS MALFUNCTION. THE TECHNICIAN HAS CHECKED ALL SUSPENSION, STEERING AND TIRE RELATED ITEMS. THE TIRES THAT ARE ON THE TRUCKS ARE LOAD RANGE E TIRES AND ARE PROPERLY INFLATED TO THE MAXIMUM PRESSURE PER THE MANUFACTURERS (BIG O) SPECIFICATIONS. ALL SUSPENSION AND STEERING PART ARE FACTORY INSTALLED OR OEM PARTS AND THE SHOCK ABSORBERS ARE HEAVY DUTY. *KB

TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHILE DRIVING 50 MPH, THE VEHICLE SHOOK VIOLENTLY. THE ENGINE MUST BE TURNED OFF IN ORDER FOR THE VEHICLE TO STOP SHAKING. THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES AND THEY REPLACED THE SWAY BAR. THE FAILURE CONTINUED AND THE DEALER STATED THAT THEY COULD NOT DIAGNOSE THE FAILURE. THE MANUFACTURER IS AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 49,000 AND CURRENT MILEAGE WAS 83,000.

OSCILLATION OF FRONT SUSPENSION. MY 2005 F350 HAVE BEEN IN FOR REPAIRS SEVERAL TIMES BOTH BY THE DEALER UNDER WARRANTY AND SINCE BY OTHER VEHICLE SERVICE AGENCIES. IT CONTINUES TO GIVE ME PROBLEMS AND AT ITS WORSE, CAUSED THE VEHICLE TO MOVE SIDEWAYS SLIGHTLY INTO THE NEXT LANE. BASICALLY I HAVE BEEN TOLD THAT ?THIS IS NORMAL? *TR

SEVERE SHAKE/ WOBBLE ON FRONT END AFTER HITTING A BUMP AT HIGHWAY SPEEDS (65 MPH+). IT HAS BEEN TO THE DEALER TWICE TO DIAGNOSE AND FIX THE PROBLEM. THEY HAVE REPLACED THE STEERING BOX, PITMAN ARM, DRAG LINK, DRAG LINK ENDS, RE-ALIGNED AND RE-TORQUED ALL OF THE FRONT END BOLTS WITH NO SOLUTION. *NM