There are 10 stored owner reports matching the powertrain & transmission leading-label group for the 2005 Ford F-350 in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 10 of 10 matching reports.
Open the full vehicle complaint log (all categories)TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING TRANSMISSION FLUID FROM A SEAL IN THE TORQUE CONVERTER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN ADVISED THE CONTACT THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 150,000 AND THE CURRENT MILEAGE WAS 168,000.
TRANSMISSION FLUID WAS LEAKING OUT FROM UNDER TRUCK AFTER I STARTED IT TO LET WARM UP. HAD IT TOWED TO THE GARAGE ONLY TO FIND OUT THAT A SNAP RING INSIDE THE TRANSMISSION HAD WORN A HOLE IN THE TRANSMISSION CASING. THIS COULD HAVE BEEN REAL BAD IF I HAD NOT LET THE TRUCK WARM UP AS I LIVE ON A HILL AND THE TRANSMISSION FLUID WAS COMING OUT SO FAST I AM SURE THE ROAD WOULD HAVE BEEN COVERED. I CHECK TO SEE IF FORD HAD RECALLED THIS PROBLEM BUT THEY DID NOT, EVEN AS THERE ARE MANY COMPLAINTS ON THE FORD FORUM WEBSITE. ALL I CAN SAY IS THERE WILL NOT BE ANOTHER FORD IN MY LIFE AFTER I REPLACE THIS TRUCK. *TR
MY 2005 FORD 350 4X4 CRACKED THE TRANS CASE BECAUSE OR THE LOW/REVERSE SNAP RING CAME LOOSE & BROKE THE TRANS CASE AT 55000 MI. TALKED TO FORD ABOUT THIS & THEY SAID THERE IS NOTHING THEY COULD DO &THERE HAS NOT BEEN A PROBLEM WITH THIS, BUT I FOUND OUT THAT THEY HAVE HAD A PROBLEM & HAD A RECALL ON THIS (RECALL #05B27). FORD DEALER SAID THAT THIS WOULD COST ME $4622.00. THEY FIXED THIS PROBLEM I THINK IN THE 2006 MODELS THEREFORE THEY KNEW THEY HAD A PROBLEM. MY WARRANTY RAN OUT ON THIS TRUCK ABOUT 1 MONTH AGO. *TR
ABOUT A MILE AFTER I TURNED OFF OF HWY 101 ONTO HWY 166 GOING EAST WHILE HAULING MY 32' TOYHAULER WITH MY 2005 FORD F350 SUPERDUTY 4X4 DRW CREW CAB TRUCK WHEN SMOKE STARTED BILLOWING OUT THE REAR OF MY TRUCK, A FRIEND THAT WAS FOLLOWING ME THOUGHT MY TRUCK WAS ON FIRE AS FLUID SPRINKLED ON HIS WINDSHIELD. I WAS NOT ABLE TO SAFELY PULL OVER FOR A COUPLE OF MILES. WHEN I STOPPED I FOUND THAT MY TRANSMISSION FLUID HAD SPEWED OUT ONTO THE TAIL PIPE OF THE TRUCK THAT CAUSED THE SMOKE AND ALL OVER THE HIGHWAY. I HAD THE TRUCK AND TRAILER TOWED TO SANTA MARIA FORD AND HAD TO WAIT A DAY FOR THEM TO OPEN. WHEN THEY INSPECTED THE TRANSMISSION, THE MECHANIC TOLD ME THAT THE PROBLEM WAS A FAULTY RETAINER (SNAP) RING THAT CAME OFF (UNSEATED) THE LOW/REVERSE CLUTCH THAT CAUSED THE CRACK IN THE TRANSMISSION CASE. THE MECHANIC TOLD ME THERE WAS A FORD RECALL ON THIS PROBLEM A FEW YEARS EARLIER. HE DID NOT WANT ME TO MENTION THAT HE TOLD ME ANYTHING TO ANYONE AT THE FORD DEALERSHIP, BECAUSE HE WAS AFRAID OF LOSING HIS JOB. I LEFT THE TRUCK AT THE DEALER BECAUSE THEY SAID IT NEEDED A REBUILT TRANSMISSION. WHEN I RETURNED HOME I RESEARCHED THE PROBLEM AND FOUND FORD RECALL 05B27 THAT WAS EXACTLY THE PROBLEM THAT HAD OCCURRED. THE RECALL STATED THAT YOU HAD TO HAVE A SNOWPLOW PACKAGE INSTALLED ON THE TRUCK TO RECEIVE THE RECALL. THIS TRUCK DID NOT HAVE THE SNOWPLOW PACKAGE. BUT, IT DID HAVE THE EXACT TRANSMISSION WITH THE FAULTY SNAP RING THAT THE TRUCKS WITH THE SNOWPLOW PACKAGE HAD. IT SHOULD NOT MATTER IF MY TRUCK HAD A SNOWPLOW PACKAGE OR NOT. FORD KNEW THAT MY TRUCK HAD THE FAULTY PART INSTALLED IN THE TRANSMISSION AND NEVER SENT ME A RECALL. I COULD HAVE HAD AN ACCIDENT OR MAY HAVE CAUSED ONE, DUE TO THIS (FORD MOTOR COMPANY KNOWN) FAULTY PART CRACKING THE TRANSMISSION CASE AND SPEWING TRANSMISSION FLUID ALL OVER THE ROAD. HWY 166 IS A VERY WINDING ROAD IN AREAS AND WHO KNOWS IF AN ACCIDENT MAY HAVE HAPPENED DUE TO THE EXCESS SLIPPERY FLUID ALL OVER THE ROAD. MY COST $4441.00. *TR
I RENTED A TRUCK FROM U-HAUL IN ELK GROVE, CA AT 4:50PM ON 8/28/08. ONCE THE VEHICLE WAS ABOVE 45MPH IT STARTED TO SHAKE VIOLENTLY AND ONCE IT WAS DARK, THE TAIL LIGHTS ON THE RIGHT SIDE WERE SHOWN TO BE NON-FUNCTIONING. THE REPRESENTATIVE DID NOT DO A VEHICLE INSPECTION WITH ME, IN FACT, HE TOOK OFF BEFORE I EVEN PULLED OUT OF THE DRIVE-WAY. I CALLED THE REPAIR SERVICE BECAUSE I FELT THE VEHICLE WAS UNSAFE AND WAS TOLD BY THE MECHANIC THEY SENT OUT THAT THE REAR END WAS COMING APART AND THAT THE POWER BRAKE SYSTEM HAD NO POWER WHEN I CAME TO A COMPLETE STOP. I INFORMED U-HAUL AND THEY INSISTED THAT I STILL DRIVE THE VEHICLE BACK TO THEIR FACILITY. I REFUSED, CITING THAT IT WAS UNSAFE AND ILLEGAL TO DRIVE A VEHICLE WITHOUT THE WORKING TAIL LIGHTS. THEY THEN CHARGED MY CREDIT CARD FOR THE RENTAL AND MILEAGE EVEN THOUGH THE VEHICLE STILL SAT IN MY DRIVE-WAY WITHOUT THEM KNOWING WHAT THAT MILEAGE WOULD BE. *TR
08/2007 AT 27,127 MILES FORD F350 SUPERDUTY WAS TAKEN IN TO DEALER FOR REPAIR DUE TO THE FOLLOWING: HESITATION UPON ACCELERATION AND TRANSMISSION CATCHING AND LOUD BANG, LIKE IT IS JERKING INTO GEAR. DEALER REPAIRED UNDER WARRANTY. 08/2008 AT 36,800 MILES (JUST OUT OF WARRANTY) TAKEN IN AGAIN FOR SAME PROBLEM AND DEALER WANT TO CHARGE US TO REPLACE TRANSMISSION. THE VEHICLE HAS NEVER BEEN USED TO PULL TRAILERS OR HEAVY EQUIPMENT SO THERE IS NO REASON FOR THE TRANSMISSION TO BE FAILING WITH SO LITTLE MILEAGE. *TR
TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHEN THE VEHICLE WAS PLACED INTO REVERSE, IT WOULD NOT BACK UP. THE VEHICLE WAS DRIVEN TO THE DEALER AND THEY STATED THAT THE REVERSE CLUTCH RETAINER RING, THE REVERSE PISTON RETAINER RING, THE CLUTCH HOUSING, AND THE TRANSMISSION CASE NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 63,726.
1. TRYING TO SHIFT TRUCK INTO 4X4 LOW 2. THE TRUCK WILL NOT SHIFT INTO 4X4 LOW. THERE IS A "SHIFT ON THE FLY" KNOB ON THE DASH AND YOU CAN SHIFT TRUCK INTO 4X4 HIGH, OR 4X4 LOW. IT WILL SHIFT INTO 4X4 HIGH BUT NOT 4X4 LOW. 3. I HAVE TAKEN THE TRUCK INTO THE DEALERSHIP TO ADDRESS THE PROBLEM. THEY VERIFIED THE PROBLEM BUT COULD NOT FIX. *TR
I HAVE A FORD F350 KING RANCH 2005 AND IT WOBBLES VIOLENTLY AFTER HITTING A BUMP OR UNEVEN PATCH. IT DOES IT ABOVE 40 MPH. DEALER HAD ME PURCHASE A STABILIZER AND THEY PUT IT ON- IT HELPED BUT DIDN'T SOLVE IT. I JUST DRIVE THE TRUCK WHEN I NEED. I TOOK IT IN 6 MONTHS LATER AND THEY SAID THEY MUST INVESTIGATE BY DEDUCTION. THEY WANTED TO CHARGE ME TO FIRST DO A BALANCE, THEN A WHEEL ALIGNMENT. I TOLD THEM NO- IT SHOULD BE A RECALL. MY FEAR IS THAT THE VIOLENT WOBBLE WILL LEAD TO OTHER PROBLEMS. HELP. *TR
2005, F350 TORQUE CONVERTER/SHIFT TRANSMISSION SNAP RING FAILED. TRUCK HAS BEEN AT DEALER FOR SEVEN DAYS, AND FORD ZONE REPRESENTATIVE SAYS THERE IS NO SILUTIONFOR THE DEFECTIVE SNAP RING. WILL NOT GIVE ANY REPAIR DATE.*AK
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Sep 3, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.