2010 Ford Fusion Powertrain & Transmission Problems

Unintended acceleration event. Entered vehicle, put my foot on the brake, cranked it, held in that position while seatbelting. Engine had a VERY loud revving sound. Within seconds vehicle moving backwards on its own. Foot still on the brake, had not touched gas pedal, had not touched gear shifter, and was still sitting straight forward with my foot on the brake and confirmed gear shifter in park. The car quickly accelerated backwards faster and brake pedal had no effect on stopping or slowing vehicle. Went approx. 30’ across parking lot and only stopped because we hit truck parked behind us. Quickly turned off engine and removed keys. Shifter still shows Park. Careful driver. No history of accidents. I found there were several thousand reported events of unintended acceleration (Ford vehicles 2002 to 2010). Ford tried to explain many as driver error or floor mat touching the gas pedal. My mat was clipped down, as designed, with no all-weather mat on top of them, and my foot did not leave the brake pedal. AI says revving as described is "classic behavior of failing Electronic Throttle Body on 2010 Fords", "Surging without touching the pedal and known defect are extremely common". Says if "Worn or failing shifter linkage/bushings vibration form high revving could make it slip into Reverse". Ford has a 19S54 recall for AntiLock Brake Systems (not notified), where "A normally closed valve may be stuck open, which may result in extended brake pedal travel". Ford reports on similar vehicles "lunging" was due to deposits in the throttle body. Ford has installed brake override on vehicles after 2010 but that doesn't protect people driving older vehicles. Please look at combo of factors that could cause this. Disappointed to read Ford purged customer acceleration reports prior to hold 5 yrs and an expert they provided at trial was someone sheltered from all research Ford had on this issue so he pushed "driver error" as the case. Clearly not here.

Driver side CV AXLE broke.

Car parking selector, cable, parking prowler/bearing or module sensor inside transmission when car is placed in park indicator indicate as in park but vehicle still motions forward as not in park and if key can be taking out an car shut off will not start because not in the park position an is tough trying to get back in park to start the vehicle but indicator indicates as car in the park position has happened 3-4 times once almost causing a accident in a shopping enter whiling trying to park in parking space an vehicle indicated as in the park position an turn off vehicle it continued to roll forward almost hitting the vehicle in front parking space

Cylinder two the brass fitting came out of the transmission, no power when trying to accelerate, for whatever reason the front driver wheel rubs and messes up the tires, the pcm will throw a wrench symbol from time to time.

The Anti-Lock Brake System (ABS) malfunctioned causing the brakes to give out while I was driving the vehicle. Luckily I was on a residential street and I was able to safely pull over, but it could have caused a major accident had it not happened in that location. After taking it to two auto-shops, both concluded that it was a problem with the ABS system. There is an open recall for the 2010 Ford Fusion for the same exact issue (Recall number: 19S54), however it does not cover the Hybrid model, even though it is the same exact issue. In order to stop the vehicle, I need to press down on the brake pedal very very hard and use the emergency brake. It is not safe to drive, and it is a substantial and costly problem with the vehicle to repair. I would like my car to be part of that recall program, or at least be able to be recalled for this issue in which there is already an open recall, except not for my specific variety of the 2010 Ford Fusion. I have had to get my car towed several times in order to transport it, as again, it is not safe to drive!

124k miles on my Fusion. My wife's car, she doesn't beat on it. Had street cleaning, had to move to other side of street, went around the block. Had very little acceleration, jerking, by the time I made it around the block an Orange Wrench came on to the dash. ( If this would of started on the express way, I wouldn't be alive to report it) Car was fine the 2 days prior, drove it, had it washed, taken in for emissions test. The following day took it in to get the wrench code scanned by my regular mechanic P2701-00 transmission friction element b apply time range/performance My mechanic told to take it in to a few Trans shops to get it checked out to see what they say. Need to replace the entire Trans... Looking at 3500.00 minimum. Unfortunately the trans problem is commonly known now for these years on the fusion. This is something a recall is needed for.

My vehicle will no longer operate in electric mode. This is a major safety concern since there is no assist from the high-voltage battery powered electric drive motor. Upon accelerating from a dead stop, there is a significant lag before the ICE kicks in and provides enough power to move the vehicle.

Power Steering Assist Fault. This message comes on occasionally when I first start the car. When I turn ignition off and back on, it usually clears up. My car has only 52k miles. Other Ford Fusion years had the same problem. Why were they recalled but not 2010? I’ve taken the car to a mechanic who has told me electronic power steering module must be replaced. I’m waiting for the estimate. $1500-$2500 out of pocket for a known manufacturer defect is unnerving. It first happened in the fall and now happens more frequently.

Driving home from the Dr.'s office the vehicle's RPM suddenly began to increase yet the vehicle was not moving faster; the Wrench icon came on, the vehicles Blind Spot Warning came on, the Speedometer went to zero and the vehicle continued to move forward at regular speed. With less than one mile to get home we were able to continue to drive the vehicle. When the vehicle was shifted into reverse to back the car into the garage, the transmission made a loud bang and jerked the car. The vehicle was driven into the garage. The fluids were checked and all are good. The vehicle was then started again and shifted into drive and the loud bang and jerk happened again. The vehicle has not been driven.

The contact owns a 2010 Ford Fusion. The contact stated that while driving at various speeds, the vehicle jerked and lunged forward. The contact then stated that while the accelerator pedal was depressed, the vehicle started losing motive power and decelerated. No warning lights were illuminated. Additionally, the contact stated that the vehicle was taken to a transmission specialist where the transmission was rebuilt and replaced. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to a transmission specialist where it was diagnosed that the transmission failed and needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure and the contact was informed that the vehicle was out of warranty. The manufacturer was notified of the failure, but no further assistance was provided. The failure mileage was approximately 40,000.

I have a 2010 Ford Fusion Hybrid that has approximately 90k miles. The car started randomly shutting off while driving. No combustion engine, no electric motor propelling the car. Suddenly shutting off while driving is incredibly unsafe. I took it to a Ford dealer and after much communication with Ford HQ, it was determined that the transmission control module was bad. This component is buried inside the hybrid cvt transmission, and as such cannot be repaired. The entire transmission needs to be replaced. After contacting about 10 large transmission shops in the region I found out that none of them can do the work. Ford has made the unit so that the information in the unit can only be copied and written with Ford software. It is impossible for a repair shop to install a used unit. The only way to repair the car is with a new transmission from Ford that I was quoted $14,000 for. This is a scam against the consumer. A decent running car is reduced to scrap value over a single component that only the dealer can repair at an exorbitant price. This is inherently unsafe and a total consumer scam.

This vehicle has been in our family since new and all recalls and service has been done on schedule. Currently only have 75K miles on it. On January 19, 2023 I was driving the vehicle in question and had a warning pop up saying Check Brake System and Service AdvanceTrac at the same time I lost my brakes and the vehicle lost power but not total power. No warning was given prior to this happening. I was able to stop the vehicle after pushing the brakes all the way to the floor and putting the car in neutral. I was luckily in my neighborhood after driving home in heavy traffic. I was able to get the car to my driveway and after restarting the car the warning went away and my husband drove the vehicle and did not have the issue. I found that Ford had a Customer Service Satisfaction internal recall back in 2010 on this vehicle for the exact same problem. The fix was applied back in 2010. I just recently brought the car in for another recall for a battery firmware update which I believe could have messed with the fix that was applied back in 2010. I called Ford and they stated there was nothing they could do. I can't get into a ford dealership for them to look into this for another 2 weeks. If other vehicles received this same firmware update for the battery they may incur the same issue and someone could be hurt or worse killed if they panic and don't know what to do. I had a hard enough time stopping the vehicle and I knew what to do but luckily I was not in traffic when it happened. I found an article written by Consumer reports back in Feburary 2010 stating the same issue. Vehicle is available for inspection at any time.

The contact owns a 2010 Ford Fusion. The contact stated while driving 30 MPH, the vehicle began to jerk forward. The contact stated no warning light was illuminated. The contact was able to continue driving to his destination. The contact stated that he had experienced the failure five times in total. The contact took the vehicle to the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 161,000.

The contact owns a 2010 Ford Fusion. The contact stated that after parking the vehicle and removing the key from the ignition switch, the vehicle rolled away. The contact stated that the parking brake was applied to stop the vehicle and then the vehicle failed to restart. The vehicle was towed to an independent mechanic but was not diagnosed or repaired and was towed back to the residence. The contact was made aware of an unknown power train recall; however, the local dealer confirmed that the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 200,000.

While driving my car 2 Wrench lights appeared on my dashboard. My car suddenly started to slow down and it would not regain speed. I had to find a safe place to pull over. When the traffic cleared I started back on my way home at a very reduced speed. This problem has occurred multiple times but my Ford dealer is unable to fix it. This problem has been addressed in Ford's "Customer Satisfaction Program 13N03 for Non-Hybrid Ford Fusions. Hybrid Ford Fusions have thee same Throttle Body Assembly part that has been replaced by Ford's Customer Satisfaction Program 13N03, so why not include Hybrid Ford Fusions too? (My car has only 61,000 miles.)

The contact owns a 2010 Ford Fusion. The contact stated that while driving at an undisclosed speed, there was a loud knocking sound coming from the vehicle, and the vehicle stalled. The transmission warning light was illuminated. The contact stated that a mechanic went to the residence and diagnosed the vehicle with transmission failure. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 75,000. THE CONSUMER REQUESTED TO BE REIMBURSED FOR THE VALUE OF THE VEHICLE OR BE REIMBURSED WITH A VEHICLE OF EQUAL VALUE.

While accelerating in my car, the transmission felt like it was slipping and jerks into gear. it happens anytime I go from a stop in the first few gears. It is very dangerous if I would have to move out of the way of traffic.

The transmission fails to shift from first to second and also is shuttering in reverse. It revs the engine and suddenly lurches forward or reverse. It becomes unsafe trying to get to traffic speed from a light or when turning. Yes the by independent service company. No it has need been inspected by a dealer or manufacturer. Warning lights came on after the first time it happened. This is a known issue with these transmissions and I believe its a manufacture failure to recall these transmisisons.

PROBLEM WITH TRANSMISSION. CHUGGING AND IRREGULAR SHIFTING

ENGINE LIGHT, ADVANCE TRAC LIGHT, ABS LIGHT, BATTERY LIGHT, TIRE PRESSURE MONITORING SYSTEM LIGHT, ALARM LIGHT SUDDENLY CAME ON. THEN DASH WENT COMPLETELY BLANK. HEADLIGHTS WENT OUT,LOST CONTROL OF VEHICLE AT HIGH SPEED. DASH LIGHTS CAME BACK ON STIRRING CONTROL OF VEHICLE LOST. ALL DASH LIGHTS STARTED FLASHING. BREAKING SYSTEM NOT WORKING.