2015 Ford Fusion Powertrain & Transmission Problems

On 2/4/26, I experienced a slight skip while driving, But did not continue. The very next morning while in reverse, A winding sound started. Put car in drive pulled out onto main road, drove fine, not even half a mile. Stopped at sign, pulled out onto main road a main road, and car would not go, would not go in gear at all. No one was hurt, but received a few horn honks. Made it to side of road, put the car in sport/manual mode, did not help. Manage to make it about a mile up the road where I was able to safely park it in a parking lot. The check engine symbol came on a couple of weeks prior, but went away after a day. Did not come back on until this particular day 2/5/26. Nothing, no problems leading up to this. Conveniently the extended warranty went out on car 4k miles ago! And the dealership is not interested in helping me out at all. I had to have it towed to an independent shop, to get checked out, due to the dealership being booked 2 months out! I now have a car that I have only had for 1 year! With a blown transmission that I have to make payments on and can not drive!! There are no recalls, but there is a manufacturer issue, that we do not get notified about by mail or by email..? I read another complaint about this same thing, guy also making payments on a car he can not drive!!! This is ridiculous!! And heartbreaking if I can not get help with this! And you can bet the dealership will receive a less than favorable review!

Date 2023-03-13 Campaign 23S12/23V162 Description On your vehicle, the front brake jounce hoses could rupture prematurely Safety Risk A ruptured front brake jounce hose will cause a progressive brake fluid leak. The driver may experience an increase in pedal travel together with a reduction in the rate of deceleration, increasing the risk of a crash. Remedy Parts are now available to repair your vehicle. Ford Motor Company has authorized your dealer to replace both front brake flexible hoses free of charge parts and labor. Next Steps Contact your dealer for more information to schedule the free service. Safety Recalls* Front brake flexible hose replacement Recall incomplete Powertrain control module pcm reprogramming Recall incomplete Customer Satisfaction Programs** Powertrain control module pcm reprogramming Recall incomplete Note: Funding to complete the many recalls are held in processing delays by DEPARTMENT OF THE TREASURY. Thus, Powertrain control module pcm reprogramming Recall incomplete

The transmission lost Park function, shifter position indicates the vehicle is in park. However, the indicator on the instrument panel indicates the vehicle is in drive. This happened after driving the car, and when I parked it. This condition allowed the ignition key to be removed with no instrument panel warning message or warning chime while exiting the vehicle indicating the vehicle is not secured in park. This could result in unintended vehicle movement, increasing the risk of injury or crash. I searched the problem online and found the problem was related a bushing in the end of the transmission selection cable. I was able to find the transmission cable. Upon close inspection, the cable was separated from the selection lever on the transmission. The end of the cable was missing the bushing. There was a safety recall in 2018, 18S20 that dealt with this problem. I had a replacement installed back in 2018. Now I am actually experiencing what the recall was supposed to correct/prevent. Is this recall still in effect? If not, can a new one be issued. I called a dealership, but they stated that the recall had expired.

The contact owns a 2015 Ford Fusion. The contact stated that while attempting to start the vehicle, the vehicle failed to start as intended. In addition, the contact noticed an abnormal sound with several unknown warning lights illuminated. The vehicle was towed to the dealer, where it was diagnosed with PCM failure. The contact was informed that the PCM needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact referenced an unknown recall with a similar failure description; however, the VIN was not under recall. The failure mileage was unknown.

The contact owns a 2015 Ford Fusion Hybrid. The contact stated while driving at an undisclosed speed, there was an abnormally loud sound coming from the engine compartment after the vehicle had switched from electric to gasoline. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 86,300.

The contact owns a 2015 Ford Fusion. The contact stated while driving 70-75 MPH on the interstate, the vehicle stalled. There was no warning light illuminated. The contact was able to pull over and restarted the vehicle. The message "Transmission Not in Park" was displayed. The contact stated that while veering to the left lane, the vehicle started to shudder. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacture was not made aware of the failure. The failure mileage was approximately 216,700.

Unintenional rollaway due to detached and degraded shift cable bushing. My car jerked me into a half spot when I pulled up to work this am. Upon looking, it would not go in gear at all. The gear shift says that it's in park and the dashboard says it's in neutral. Upon opening the hood and examining, I found that the bushing on the transmission cable was broken. I had no way to go so I called the Ford dealership and had someone let me pay over the phone for the part and I sent a coworker to pick up. Then I called a tow truck to tow my vehicle to Total Tire Care in Statesboro Georgia. I am going to have to pay the labor fee and also be without a vehicle all day. There are several 2015 Ford Fusions that have had a recall on this very part - but not my VIN. I think this needs to be changed and I should be able to have the cable inspected and replaced as needed.

The contact owns a 2015 Ford Fusion. The contact stated that while attempting to accelerate from a stop, the RPM became elevated, the engine revved up, and there was an abnormally loud clunking or thumping sound before the transmission shifted into gear and the vehicle accelerated. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who informed the contact that there were contaminants in the transmission fluid, making the transmission fluid dark, and causing the transmission to fail. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The dealer was contacted and confirmed that the VIN was not under recall. The manufacturer was not informed of the failure. The failure mileage was approximately 122,000. The VIN was not available.

Cable and bushing detached for a third time. I called ford and they said there was not a recall for this issue. I’ve read in multiple places that this has happened to a lot of ford fusions.

My transmission was serviced under the cable bushing recall - since then the main complaint is the grinding, loss of power, losing gears etc. the rear camera also fails to function over half of the time. this has been validated by fletcher car care. they said the transmission is now faulty. i have seen this issue repeated throughout the other safety reports on your website. this is an overarching issue that should've been addressed by the manufacturer. there were no warning lamps messages or symptoms of the problem prior to the failure. this car is a safety hazard and it is negligence to allow the issue to persist. the problem was reproduced by the shop, fletcher car care - Fletcher Car Care is an auto repair shop located at 38 Heritage Park Dr, Fletcher, NC 28732 - the issues i believe began when the cable bushing began changing the linkage between the shifter and transmission around march. this was when i started having issues with the rear camera - the rear camera at times is full of artifacts and interference because i believe it is in a intermediate (out of full engagement position)

The contact owns a 2015 Ford Fusion. While the contact's brother-in-law was parking the vehicle, the gear shifter was shifted into park(P); however, after exiting the vehicle, the vehicle rolled backward. The contact's brother-in-law enabled the parking brake to stop the vehicle. The contact's brother-in-law noticed that the gear shifter had independently shifted into neutral(N). The dealer was made aware of the failure. The contact was informed of an undisclosed recall repair for the failure; however, the VIN was not included. The contact was informed that the shifter bushing needed to be replaced. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was 146,695.

The contact's girlfriend owns a 2015 Ford Fusion. The contact stated while driving at approximately 30 MPH, the transmission hesitated to shift into the intended gear; while the vehicle was parked, the vehicle independently moved. She had to pull to the side of the road for several minutes and shut the vehicle off in order for the vehicle to return to normal operation. No warning light was illuminated. The failure occurred on several different occasions. The contact did research and was made aware of the NHTSA Campaign Number: 22V413000 (Power Train) however, the VIN was not included. The vehicle was towed to an independent mechanic to get a diagnosis; the diagnosis was unknown. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown.

The contact owns a 2015 Ford Fusion. The contact stated that after shifting into reverse, the transmission shifter became inoperable, and the transmission could not be shifted into gear. The vehicle was towed to the local dealer who diagnosed that the transmission shifter cable bushing had failed and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 22V413000 (POWER TRAIN). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 151,000.

The contact owns a 2015 Ford Fusion. The contact stated that after parking in the driveway and shifting to park, the contact exited the vehicle with the engine idling and the front driver’s side door opened. The contact walked down the driveway to retrieve the mail and suddenly the vehicle erroneously rolled down the driveway. The opened door struck and knocked the contact to the ground. The contact reached inside the vehicle and depressed the brake pedal to stop the vehicle from rolling while his wife engaged the parking brake. During the failure the contact sustained a separated right shoulder. No medical treatment was received. The cause of the failure was not yet determined. The manufacturer and local dealer were contacted but no assistance was provided. The contact was informed that the VIN was not included in NHTSA Campaign Number: 22V413000 (Power Train). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 121,000.

The contact owns a 2015 Ford Fusion. The contact stated while driving at an undisclosed speed into a gas station, the contact shifted the transmission into reverse(R); however, the transmission inadvertently shifted into park(P). The transmission fault message was displayed. The contact stated that the transmission seized while in park(P). The vehicle was towed to the dealer, and the contact was informed that the vehicle had previously been repaired under NHTSA Campaign Number: 18V471000 (Power Train), but the failure persisted. The dealer determined that the shifter cable bushing needed to be replaced for the second time. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 147,000.

The contact owns a 2015 Ford Fusion. The contact stated while driving at an undisclosed speed, the contact became aware of a failure with the transmission. The contact stated that the gear shifter seized and remained in drive. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the shifter cable bushing had detached and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and the contact was referred to NHSTA Hotline for assistance. The failure mileage was approximately 225,974.

Transmission went out on the highway.

The contact owns a 2015 Ford Fusion. The contact stated that while the vehicle was turned off with the gear shifter in park(P), the vehicle began to roll forward while the contact was in front of the vehicle. The vehicle was on an incline and independently stopped after rolling forward. The vehicle was taken to an independent mechanic where the mechanic informed the contact of NHTSA Campaign Number: 22V413000 (Power Train) which the mechanic linked to the failure. The dealer was notified of the failure and informed the contact that the VIN was not included in the recall. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 190,000.

The contact owns a 2015 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle seemed to shift improperly, after which the contact heard an abnormal rattling noise coming from underneath the vehicle. The vehicle was taken to the dealer, who diagnosed a failure with the transmission flex plate. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 22N12. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

I noticed the coolant level keeps getting low. There was a large amount of white smoke coming from the exhaust. It sounds like water in the dash. Now the car is barely drivable. No warning lights have come on.