2004 Lexus RX Body & Structure Problems

THE DASHBOARD IS CRACKING UP VERY BAD

TL* THE CONTACT OWNS A 2004 LEXUS RX330. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR AN UNKNOWN RECALL. THE CONTACT REFERENCED TECHNICAL SERVICE BULLETIN NUMBER: POL14-03 (CRACKED DASHBOARD). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. WEST SIDE LEXUS (12000 KATY FWY, HOUSTON, TX 77079, (281) 558-3030) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT STATED THAT THE VEHICLE WAS ALSO INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V112000 (VEHICLE SPEED CONTROL). THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2004 LEXUS RX330. THE CONTACT STATED THAT WHILE INSPECTING THE INTERIOR OF THE VEHICLE, HE NOTICED THAT THE DASHBOARD ON THE DRIVER'S AND PASSENGER'S SIDE AIR BAG ENCLOSURE AREA WAS CRACKED. POHANKA LEXUS (13909 LEE JACKSON MEMORIAL HIGHWAY, CHANTILLY, VA 20151, (703) 968-9100) WAS INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VIN WAS NOT UNDER RECALL. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE HOWEVER, NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 103,000.

TL* THE CONTACT OWNS A 2004 LEXUS RX330. THE CONTACT STATED THAT THE DASHBOARD EXPERIENCED SEVERE CRACKING. THE CONTACT WAS CONCERNED THAT THE DEBRIS FROM THE CRACKING COULD POTENTIALLY BECOME SHRAPNEL THAT COULD CAUSE INJURY IN THE EVENT OF AN AIR BAG DEPLOYMENT. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST SINCE IT WAS CONSIDERED A COSMETIC FAILURE. THE FAILURE MILEAGE WAS 116,000.

TL* THE CONTACT OWNS A 2004 LEXUS RX330. THE CONTACT STATED THAT THE DASHBOARD EXPERIENCED MELTING AND CRACKING. ALSO, SEVERAL SECTIONS OF THE DASHBOARD SEPARATED AND FELL OFF. IN ADDITION, WHILE DRIVING, A GLARE FROM THE SUNLIGHT WAS PRESENT ON THE MELTED DASHBOARD, WHICH CAUSED A VISIBILITY HAZARD. THE CAUSE OF THE FAILURES WAS NOT DETERMINED. THE MANUFACTURER AND LOCAL DEALER( LEXUS OF COOL SPRINGS, 1636 WESTGATE CIR, BRENTWOOD, TN) WERE BOTH NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 92,000.

TL* THE CONTACT OWNS A 2004 LEXUS RX. THE CONTACT STATED THAT THE DASHBOARD WAS CRUMBLING AND MELTING. THE FAILURE WAS PRESENT NEAR THE PASSENGER SIDE AIRBAG HOUSING OF THE DASHBOARD. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER (BUTLER LEXUS LOCATED AT 4025 JONESBORO RD, UNION CITY GA) AND THE MANUFACTURER WERE NOTIFIED BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 140,000.

TL* THE CONTACT OWNS A 2004 LEXUS RX330. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR AN UNKNOWN RECALL. THE CONTACT REFERENCED TECHNICAL SERVICE BULLETIN NUMBER: POL14-03 (CRACKED DASHBOARD). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. WEST SIDE LEXUS (12000 KATY FWY, HOUSTON, TX 77079, (281) 558-3030) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT STATED THAT THE VEHICLE WAS ALSO INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V112000 (VEHICLE SPEED CONTROL). THE CONTACT HAD NOT EXPERIENCED A FAILURE.

MELTING DASHBOARD. *TR

OVER THE LAST 2 MONTHS I HAVE NOTICED A DETERIORATION OF THE DASHBOARD AS CRACKS AND PEELING HAVE OCCURRED . THE REST OF THE VEHICLE IS IN FINE CONDITION. I ASSUME THAT THE FLORIDA CLIMATE HAS SOMETHING TO DO WITH IT. HOWEVER, I MUST POINT OUT THAT MY VEHICLE IS NORMALLY PARKED IN THE BASEMENT OF A CONDOMINIUM WHERE I HAVE BEEN RESIDING DURING THE ENTIRE PERIOD THAT I HAVE OWNED THE VEHICLE. I DID CALL THE CUSTOMER RELATIONS DEPT. OF LEXUS AND WAS INFORMED THAT THE WARRANTY HAD EXPIRED AFTER 4 YEARS OR 50,000 MILES. I HAPPENED TO EXAMINE A 1990 MERCEDES BENZ SEDAN AND NOTICED THAT THE DASHBOARD WAS COMPLETELY INTACT. I UNDERSTAND FROM MEDIA COVERAGE THAT THERE HAVE BEEN NUMEROUS COMPLAINTS ABOUT THE DASHBOARD'S CONDITION. *TR

MY 2004 LEXUS RX330 HAS HORRIBLE PAINT ISSUES ON THE FRONT BUMPER. PAINT STARTED CHIPPING OFF IN HUGE SECTIONS AND IT LOOKS TERRIBLE. THIS HAS ONLY HAPPENED ON THE FRONT BUMPER AND THE REAR VIEW MIRRORS. SEEMS LIKE THE PAINT IS DEFECTIVE IN THESE AREA'S. SO DISAPPOINTED. ALSO THE TRANSMISSION IS MESSED UP. SEEMS LIKE IT HOPS IN BETWEEN 1-2 RPM. I EVEN HAD THE TRANSMISSION REBUILT AND IT STILL DIDN'T FIX THE ISSUE. IT STILL DOES IT. I HAVE HEARD THAT THIS IS A MAJOR ISSUE WITH THESE VEHICLES.

TL* THE CONTACT OWNS A 2004 LEXUS RX330. THE CONTACT INDICATED THAT THERE WAS AN INTERMITTENT LEAK COMING FROM THE MOON ROOF CAUSING MOLD TO DEVELOP WITHIN THE VEHICLE. THE VEHICLE WAS TAKEN TO THE AUTHORIZED DEALER ON SEVERAL OCCASIONS. THE TECHNICIAN WAS NOT ABLE TO REMEDY THE FAILURE. THE VEHICLE WAS TAKEN TO ANOTHER AUTHORIZED DEALER WHO INDICATED THAT THERE WAS A REAR BODY SEAM LEAK AND THAT THE RIGHT FRONT MOON DRAIN WAS IMPROPERLY ROUTED. THE DEALER RESEALED THE RIGHT FRONT MOON ROOF DRAIN AND REROUTED IT, ALONG WITH RESEALING BOTH TAIL LAMP BUCKETS. THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES. THE TECHNICIAN STATED THAT THE CARPET NEEDED TO BE REPLACED. THE CONTACT WAS NOT ABLE TO DRIVE THE VEHICLE DUE TO THE CONTINUING LEAK AND MOLD. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 01/07/14*LJ UPDATED 9/5/2017*CN

I WAS RECENTLY GIFTED MY MOTHER'S 2004 LEXUS RX330 AND HAVE BEEN NOTICING FOR SOME TIME NOW AN EXTENSIVELY CRACKED DASHBOARD THAT HAD BEEN GETTING PROGRESSIVELY WORSE FOR THE PAST SEVERAL YEARS. IN ADDITION, THERE ARE SEVERAL STICKY SPOTS ON THE DASH WHICH APPEARS TO BE MELTING MATERIAL. I HAVE SEEN THIS COMPLAINT ONLINE REPEATEDLY FROM OTHER RX330 OWNERS AND WAS WONDERING IF THERE IS A CLASS ACTION SUIT. THERE IS STILL AN EXTENDED WARRANTY ON THE CAR. AFTER CONTACTING THE DEALERSHIP IN MIAMI THEY HAVE REFUSED TO COVER THE ENTIRE COST OF REPAIR. THIS IS CLEARLY A MANUFACTURER DEFECT. *TR

THIS VERY METICULOUSLY MAINTAINED GARAGED VEHICLE BEGAN TO CRACK OVER THE TOP OF THE AIRBAG ON THE PASSENGERS SIDE. IT CONTINUES TO GROW. IT IS NOW VERTICALLY CRACKED ABOUT 4 INCHES. IT IS ALWAYS GARAGED PARKED AT WORK AND AT HOME. THE SUN HAS HAD ZERO EFFECT ON THIS OVER THE LAST TWO YEARS OF OWNERSHIP. NOT SURE PRIOR TO THE 2 YEARS. I SEE FROM THE INTERNET THIS SEEMS TO BE A COMMON ISSUE WITH THIS CAR. *TR

I FIRST NOTICED CRACKS IN THE PLASTIC IN SEVERAL PLACES RUNNING VERTICALLY ON BOTH SIDES OF MY DASHBOARD AND IT LOOKED LIKE IT WAS WET. IT WAS VERY STICKY TO THE TOUCH AND LEFT A RESIDUE ON MY FINGERS LIKE PINE TAR. MY CAR IS NOT SITTING IN THE HOT SUN AND IS GARAGED FOR THE MOST PART UNLESS GOING TO THE STORE. *TR

I HAVE A SEVERELY CRACKED DASHBOARD AND A LOT OF THE VERY DEEP CRACKS ARE OVER WHERE THE PASSENGER AIRBAG IS LOCATED. THIS HAS BEEN A PROBLEM FOR A FEW YEARS NOW BUT LATELY IT HAS GOTTEN MUCH WORSE IN THE AREA OF THE AIRBAG. LEXUS ACKNOWLEDGES THE PROBLEM BUT THEY SAY IT COULD BE SEVERAL MORE MONTHS OR EVEN YEARS BEFORE THEY HAVE ENOUGH REPLACEMENT DASHBOARDS. I BELIEVE MY DASHBOARD IS MORE OF A SAFETY ISSUE THAN JUST COSMETIC. UNABLE TO ATTACH PHOTOS BUT COULD EMAIL THEM TO YOU IF AN EMAIL ADDRESS IS PROVIDED. *TR

THE DASHBOARD IS DISINTEGRATING. THE CAR HAS BEEN PREDOMINANTLY KEPT COVERED AND WELL MAINTAINED. INITIALLY A LARGE PIECE (CREDIT CARD SIZE) BROKE OFF DASH. WE REPAIRED WITH VINYL RESTORATION COMPANY, AND ANOTHER AREA ABOUT A YEAR LATER. SINCE THEN, NUMEROUS CRACKS ARE PRESENT - TOO MANY TO REPAIR. THIS IS NOT NORMAL WEAR! *TR

APPROXIMATELY A YEAR AFTER PURCHASING MY 2004 LEXUS RX330 FROM A DEALERSHIP THE DASH BOARD STARTED TO CRACK. EVENTUALLY, IT TRAVELED ACROSS THE ENTIRE DASH BOARD. I CONTACT LEXUS CORPORATE OFFICE TO COMPLAIN. AFTER REFERRING ME TO A LOCAL DEALERSHIP TO EXAMINE IT AND TAKE PHOTOS AND WRITE UP THE DAMAGE, THEY LATER TOLD ME IT WAS NOT COVERED UNDER THE WARRANTY WHICH I ALREADY KNEW. HOWEVER, THEY ADMITTED IT WAS DUE TO INFERIOR AND FAULTY MATERIAL LEXUS USED IN 2004 THRU 2006 IN THEIR MODELS AND ALSO TOYOTA DASHBOARDS. THE COST TO REPLACE THE DASH IS $2,500 THIS IS MY 3RD LEXUS SUV BUT IT WILL BE MY LAST! I FEEL LEXUS SHOULD BE RESPONSIBLE TO REPLACE THE DASH BOARDS. *TR

MY 2004 LEXUS RX330'S DASHBOARD HAS BEEN CRACKING SINCE THE DAY I PURCHASED IT. THE VEHICLE ORIGINATED IN FLORIDA AND NOW IN SOUTH CAROLINA. THE HEAT AND HUMIDITY HAVE DESTROYED THIS CAR! WHEN I PURCHASED IT USED, THE DASHBOARD HAD A COUPLE OF CRACKS IN IT SO I ASSIDUOUSLY USED A WINDOW SHIELD EVERY SINGLE TIME I GET OUT OF THE VEHICLE. THE TASK IS SUCH A HABIT THAT I EVEN DO THIS UNNECESSARILY AT NIGHT! THE HEAT INSIDE THE CAR STILL COMPLETELY MELTS THE DASH TO NO AVAIL. SOMETIMES WHEN I TURN THE KEY, MY FINGERNAIL WILL ACCIDENTALLY TOUCH THE DASH MATERIAL (IT WRAPS SO IT SURROUNDS THE IGNITION) AND THE MATERIAL WILL COME OFF UNDER MY FINGERNAIL. CRANKING YOUR VEHICLE IS NOT A FORCEFUL ENDEAVOR EITHER, IT IS GENTLE AND I AM VERY CONSCIOUS NOT TO TOUCH THE DASHBOARD MATERIAL BECAUSE OF THIS MELTING ISSUE. ONE WOULD THINK THAT A BRAND SUCH AS LEXUS WOULD BE EMBARRASSED TO HAVE THESE VEHICLES SEEN IN PUBLIC! *TR

THE LEXUS DEVELOPED A SERIES OF CRACKS RUNNING THROUGHOUT THE PLASTIC DASHBOARD. THE CRACKS WORSENED OVER TIME. *JS

TL* THE CONTACT OWNS A 2004 LEXUS RX330. THE CONTACT STATED THAT THERE WERE CRACKS ON THE DASHBOARD ON TOP OF THE AIR BAG AND OTHER LOCATIONS. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION BUT THE DEALER PROVIDED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 105,000.