2005 Lexus RX Lighting Problems

HEADLIGHT LOWBEAM FAILURE DUE TO EXCESS WATER CONDENSATION INSIDE LIGHT ASSEMBLY. IT IS A MANUFACTURING DEFECT THAT LEXUS HAS KEPT SECRET THROUGHOUT THE YEARS. INSTEAD IF ISSUING AN EXPENSIVE RECALL ON ALL THE YEARS AFFECTED, THEY SIMPLY FIXED AS THE CARS CAME IN WITH THE PROBLEM. THEY KNOW THAT IT IS CHEAPER FOR THEM TO DO SO IN THAT MANNER BECAUSE MOST LEXUS OWNERS GARAGE THEIR VEHICLES AND WONT HAVE THE FAILURE UNTILL IT IS TOO LATE. THEIR PROGRAM TO FIX THE PROBLEM ENDS WITHIN A 10 YEAR PERIOD. CAN YOU INVESTIGATE AND FORCE LEXUS TO ISSUE A RECALL ON ALL CARS AFFECTED REGARDLESS AGE OR OWNERSHIP. MY LIGHTS FAILED DURING THE RAIN AT NIGHTWHILE GOING HOME. IT REALLY IS A VERY IMPORTANT SAFETY ISSUE.

TL* THE CONTACT OWNS A 2005 LEXUS RX330. THE CONTACT STATED THAT THE HEADLIGHTS SEIZED WITHOUT WARNING. THE FAILURE WAS PERSISENT. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENTIRE HEADLIGHT ASSEMBLY FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS APPROXIMATELY 109,000.

TL* THE CONTACT OWNS A 2005 LEXUS RX330. WHILE DRIVING APPROXIMATELY 30 MPH, THE HEADLIGHT DIMMER CREATED POOR VISIBILITY. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE DEALER STATED THAT THE HEADLIGHT ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 100,000. UPDATED 03/24/15*LJ UPDATED 9/18/2017*CN

I WILL ADD MY COMPLAINT TO PREVIOUS REPORTER. I HAVE HAD TO REPLACE THE HEADLAMP 2 TIMES DUE TO WATER IN THE ASSEMBLY OF THE HEADLAMP. THE RIGHT SIDE HEADLIGHT FAILED. THERE IS MOISTURE UNDER THE GLASS WHICH SHORTED OUT THE LIGHT. ONLINE I HAVE SEEN HUNDREDS OF COMPLAINTS ABOUT THIS HAPPENING TO THE SAME MODEL LEXUS. THE REPAIR FOR THIS HEADLIGHT RUNS OVER $1,500. LEXUS CORPORATION REFUSES TO TAKE RESPONSIBILITY FOR AN OBVIOUS DESIGN FLAW. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE RIGHT SIDE HEADLIGHT FAILED. THERE IS MOISTURE UNDER THE GLASS WHICH SHORTED OUT THE LIGHT. ONLINE I HAVE SEEN HUNDREDS OF COMPLAINTS ABOUT THIS HAPPENING TO THE SAME MODEL LEXUS. THE REPAIR FOR THIS HEADLIGHT RUNS OVER $1,500. LEXUS CORPORATION REFUSES TO TAKE RESPONSIBILITY FOR AN OBVIOUS DESIGN FLAW. *TR

LEXUS RX 330 HEADLIGHT ASSEMBLY IS DEFECTIVE. EVERYTIME I WASH MY RX330 OR IF IT RAINS, WATER LEAK IN THE HEADLIGHT ASSEMBLY CREATES MOISTURE INSIDE THE HEADLIGHTS. THIS CAUSES LESS VISIBILITY AT NIGHTS AND IS A SAFETY ISSUE. THERE ARE SEVERAL HUNDRED COMPLAINTS FOR THE SAME ISSUE ON THE WEB; HOWEVER, LEXUS/TOYOTA WILL NOT RECALL THEIR DEFECTIVE HEADLIGHT ASSEMBLY. THEY ARE EVEN RELUCTANT TO ACKNOWLEDGE THAT THIS IS AN ISSUE. WILL APPRECIATE IF NHTSA INVESTIGATES THIS ISSUE AND TAKE NECESSARY ACTION AGAINST LEXUS ASAP. *TR

DRIVERS SIDE HEADLAMP GOT WATER INSIDE THE HOUSING CAUSING THE HID HEADLIGHT TO SHORT OUT. HOUSING SEEMS TO BE FULLY SEALED.

WATER ROUTINELY COLLECTS INSIDE OF BOTH HEADLIGHTS WHENEVER I WASH THE CAR OR WHEN RAINING. LIGHT FAILURE DUE TO WATER INSIDE OF THE HEADLIGHTS IS REPORTED BY MANY OTHER RX330 OWNERS ON VARIOUS INTERNET FORUMS. I'M VERY AFRAID THAT LIGHTS MIGHT FAIL WHEN DRIVING AT NIGHT. THIS IS A SAFETY ISSUE. LEXUS REFUSES TO RECOGNIZE THE PROBLEM AND TO ISSUE A RECALL SINCE SO MANY CARS ARE AFFECTED. LOCAL DEALER ADMITTED THAT THERE IS A WIDESPREAD PROBLEM. PLEASE HELP. *TT

I AM DESCRIBING AN EVENT THAT OCCURS REPEATEDLY AMONG OLDER DRIVERS. THEY PUT THEIR TURN SIGNAL ON, AND IT DOES NOT SWITCH OFF AND THEY DON'T KNOW IT BECAUSE THEIR HEARING ABILITY HAS DIMINISHED. THEY THEN MAKE A TURN TO THE OPPOSITE DIRECTION OF WHAT THEIR TURN SIGNAL INDICATES AND EITHER CAUSE AN ACCIDENT OR HAVE A CLOSE CALL. *TR

I OWN A 2005 LEXUS RX 330. I HAVE BEEN HAVING A PROBLEM WITH THE CONDENSATION BUILD UP WITHIN THE HEADLIGHT FOR ABOUT 6 MONTHS. I WENT TO THE LEXUS DEALER TO FIND OUT THE PROBLEM THEY CHARGED A $110.00 SERVICE CHARGE TO TELL ME THAT I NEED TO REPLACE MY HEADLIGHT ASSEMBLY. THE COST TO REPLACE IS ABOUT $2,200. THIS IS A DISGRACE. MY HEADLIGHT DOES NOT WORK AT ALL. I HAVE NOT BEEN ABLE TO DRIVE MY VEHICLE AT NIGHT FOR SOMETIME NOW. I CONTACTED LEXUS CUSTOMER CARE AND EXPLAINED TO THEM THAT THIS SEEMS TO BE A MAJOR PROBLEM AND THEY SHOULD HAVE DONE A RECALL ON THIS VEHICLE. THE RESPONSE FROM LEXUS IS THAT THEY WOULD REVIEW MY CASE AND SOMEONE WOULD CALL ME BACK WITH A DECISION. SOMEONE DID CALL ME BACK OFFERING TO PAY 25% OF THE TOTAL BILL OF 2,200 FROM THE LEXUS DEALERSHIP. I WAS LIVID. LEXUS SELLS DEFECTIVE VEHICLES AND EXPECTS CUSTOMERS TO PAY THE REPAIRS. I DON'T KNOW WHAT THIS WORLD IS COMING TO, BUT THIS IS RIDICULOUS. THE MILEAGE FAILURE WAS 89,000. I WILL NEVER BY LEXUS AGAIN. *TR

PASSENGER SIDE HEADLIGHT FIXTURE LEAKS AND LOW BEAM LIGHT STOPPED WORKING. *TR

2005 LEXUS RX330. THE CONTACT STATED THAT THE RIGHT SIDE FRONT HEADLIGHT FAILED TWICE IN PAST 18 MONTHS DUE TO WATER CONDENSATION IN HEADLIGHT ASSEMBLY AND ECU. 1ST TIME WAS REPLACED UNDER WARRANTY. SECOND FAILURE WAS AFTER WARRANTY PERIOD AND LEXUS CORPORATE STATED IT WAS A DIFFERENT ISSUE AND REFUSED TO REPLACE. ESTIMATE TO REPLACE BY DEALER IS $1,600.00. *TR

MOISTURE PROBLEM IN BOTH FRONT HEADLIGHTS OF MY 2005 LEXUS RX330. ONE WAS REPLACED 2 YEARS AGO UNDER WARRANTY THE OTHER MARCH 2010 WHICH WAS COVERED UNDER THE GOODWILL WARRANTY. BRING YOUR CAR TO LEXUS FOR SERVICE ALL THE TIME AND YOU GET THE LITTLE PERKS. *TR

TL*THE CONTACT OWNS A 2005 LEXUS RX330. THE CONTACT STATED THAT IN THE PAST SIX MONTHS THAT THE FRONT HEADLIGHTS HAVE BURNED OUT BECAUSE THE RUBBER SEAL USED WAS NOT OF GOOD QUALITY. THE DEALER STATED THAT WAS THE TRIM AND IT WAS NOT COVERED UNDER WARRANTY. EACH HEAD LAMP HAD A COMPUTER AND THE LACK OF SEAL ALLOWED WATER INTO THE HEAD LAMPS AND SHORT CIRCUIT THE COMPUTER. THE PASSENGER SIDE HEAD LIGHT WAS REPLACED AND THE DRIVER SIDE HAS CONDENSATION INSIDE OF IT. THE FAILURE MILEAGE WAS 88000 AND CURRENT MILEAGE WAS 96000.

MOISTURE INVADES SEALED HEADLAMP HOUSING CAUSING LAMP(S) TO FAIL. LEXUS HAS REDESIGNED THE PART. NO VOLUNTARY RECALL EVEN THOUGH LEXUS KNOWS THIS IS A DEFECTIVE PART. OUT OF WARRANTY REPLACEMENT COST IS $1650 FOR ONE HEADLAMP ASSEMBLY PLUS 1HR. LABOR. THAT'S NEARLY $2000 FOR ONE HEADLIGHT!! *TR

THE PASSENGER SIDE HEADLAMP OF THE RX330 CEASED OPERATION DUE TO A BUILDUP OF MOISTURE. CONDENSATION HAS BEEN PRESENT IN THE HEADLAMP FOR SOME TIME, BUT THERE WERE NO INDICATIONS THAT IT WOULD LEAD TO HEADLAMP FAILURE. THE SUV IS MAINTAINED BY THE DEALERSHIP EXCLUSIVELY, AND AT NO POINT DID THEY MENTION THE POSSIBILITY THAT THE CONDENSATION COULD CAUSE FAILURE. THE FAILURE OCCURRED AT NIGHT IN A DARK SECTION OF HIGHWAY AND COULD HAVE LED TO SERIOUS BODILY HARM OR DEATH. LEXUS HAS BEEN AWARE OF THE PROBLEMS WITH THE RX330 HEADLAMPS SINCE 2005 AND HAS FAILED TO REMEDY THE PROBLEM. THE MOISTURE ISSUES COULD POTENTIALLY RESULT IN SERIOUS HARM TO THE DRIVER AND OCCUPANTS OF THE LEXUS OR OTHER MOTORISTS. *TR

TL* THE CONTACT OWNS A 2005 LEXUS RX330. THE CONTACT STATED THAT THERE WAS CONDENSATION ON THE DRIVER'S SIDE HEADLIGHT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THE TECHNICIAN STATED THAT THE HEADLIGHT WOULD HAVE TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. ..UPDATED 12-26-13 *BF

CONDENSATION BUILDUP HAS FORMED FROM THE INTERIOR OF THE DRIVER/PASSENGER HEADLIGHTS. THIS IS DUE TO A MANUFACTURER DESIGN FLAW OF THE HEADLIGHT SEAL WHICH ALLOWS WATER TO PENETRATE THE HEADLIGHT HOUSING. WATER DAMAGE HAS CAUSED THE LOWBEAM LIGHTS TO FAIL. LEXUS HAS QUOTED OVER $1400 FOR REPLACEMENTS, AND FAILS TO ACKNOWLEDGE THEIR DESIGN FLAW. IMPACTED VISIBILITY WHILE DRIVING WILL LEAD TO AN ACCIDENT. *TR

CONDENSATION IN HEADLAMP ASSEMBLY CAUSING HEADLIGHT TO BLOW. HEADLAMP ASSEMBLY COSTS $1,900 EA. TO REPLACE. LEXUS RX330. VEHICLE HAS BEEN OFF WARRANTY FOR ALMOST 2 MOS. 62,700 MILES ON VEHICLE. LEXUS CUSTOMER SATISFACTION SAYS THEY ARE NOT RESPONSIBLE FOR REPAIR. LEXUS DEALERSHIP WILL GIVE US A DISCOUNT (FEW HUNDRED DOLLARS). CANNOT DRIVE VEHICLE WITH NO HEADLIGHTS AT NIGHT. RESEARCH SHOWS A NUMBER OF LEXUS RX330 HEADLAMP PROBLEMS. VEHICLE CANNOT BE REPAIRED BY ANYONE OTHER THAN LEXUS AS THIS IS A COMPUTER ASSEMBLY REPLACEMENT. RAIN HEAVY, CONDENSATION BUILDS UP INSIDE ASSEMBLY CAUSING SHORT AND BLOWING OUT HEADLIGHT. *TR

TL* THE CONTACT OWNS A 2005 LEXUS RX330. WATER ENTERS THROUGH THE HEAD-LIGHTS. THE VEHICLE WAS TAKEN TO THE DEALER AND HE WAS ADVISED THAT IT COST $1000 TO REPLACE THE HEADLIGHT ASSEMBLY. NO REPAIRS WERE MADE. THE FAILURE MILEAGE WAS 63,000.