2007 Toyota FJ Cruiser

The contact owns a 2007 Toyota FJ Cruiser. The contact stated that while her son was attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to an independent mechanic; however, no cause for the failure was found. The independent mechanic informed the contact that the undercarriage and subframe were severely corroded. The contact was informed that the vehicle should not be driven because the wheels might detach from the vehicle. The vehicle remained with the dealer unrepaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 185,000.

I am the owner of a Toyota FJ Cruiser (Year:2007), VIN: [XXX] ]) equipped with the TRD High-Performance Brake Kit, which is under recall campaign C0R / NHTSA 12E046. I recently experienced a serious safety issue involving the front TRD brake crossover tube. While driving, I suddenly noticed a soft brake pedal and significant loss of braking power. I was unable to stop the vehicle properly and nearly crashed into another car at an intersection. I had to swerve at the last moment, which could have caused a more serious accident. Upon inspection, I found that brake fluid was leaking from the crossover tube—exactly the defect described in the TRD brake recall. This failure happened without warning, and my safety and the safety of others was clearly at risk. This is unacceptable for a safety recall. I am requesting immediate investigation, assistance, and a permanent solution. Toyota must ensure this part is properly redesigned and replaced, and that no vehicle is left on the road with this faulty setup. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2007 Toyota FJ Cruiser. The contact stated that the front driver's side seat belt failed to retract. The contact related the failure to NHTSA Campaign Number: 13V098000 (Seat Belts). The dealer was notified of the failure and informed the contact that the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 158,305.

While towing my boat, the rear frame to which the trailer hitch is a part of, ripped down both side of the frame. Basically, the rear frame of the truck is barley holding on by rust. The hitch and frame section are dangling down. Rust has completely eaten through the entire frame after closer inspection.

Silver paint is peeling off the hood, bumper, doors, ect

My fj cruiser has terrible rust on the frame. It literally looks like it was stored in the ocean for 50 years. This vehicle is from 2007 and should not have this much rust.

The fj cruiser is a common issue for rot/ rust on the frame of the vehicle, I have clean the frame often during the winter months and my frame is continuously rusting and rotting the frame of the vehicle I have decided to not drive the vehicle till the frame is either replaced or repaired due to the safety concern of driving it on the road, numerous others have same incidents of the holes in the frame due to rust the manufacturer did not put any kind of corrosion treatment on the frame to stop this from happening the frame flexes when accelerating and is not safe for anyone to including my passengers or other people on the road

-Toyota recalled the vehicles using the same/similar frame has the same rusty issues, like Tacoma. This recalled made me pay attention on this issue and I found the my FJ cruiser is no longer 100% safe while driving. -The frame of the body is very rusty after years which is not normal. I believe most owners of this model having the same issue. There are rust everywhere under the body, when change some parts, it was really hard to do so, need the fire gun to burn all the screws. And the exhaust system all rusty and leaked as well, cost me a lot of money to fix. -The frame may broken anytime while driving which is risky to me and my passengers. -No dealers would like to fix that frame for me unless to pay a huge amount of Labour costs, which is higher than the value of the car. -it has been inspected by more than 5 car specialists and body shop workers, saying that frame is dying and won’t last for long, maybe will completely broken in a few years. -There is no issues on mechanics, just the under body rust. It happened a lot of years maybe 5-7 years before. -I’m from Canada.

DRIVER SIDE SEATBELT DOES NOT RETRACT ON MY 2007 TOYOTA FJ CRUISER.

The contact owns a 2007 Toyota FJ Cruiser. The contact stated that the driver's side seat belt failed to retract, causing the contact to have to manually put the seat belt in place. The contact stated that the failure recurred several times and progressed where the seat belt would not retract. The contact discovered NHTSA Campaign Number: 13V098000 (Seat Belts) and the dealer was contacted, and it was confirmed that the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 191,700. The contact stated vehicle has been repaired, and this case may be closed.

Frame and undercarriage have excessive wear for age of vehicle despite normal maintenance and care. Rust and corrosion has made the vehicle unsafe to drive.

Frame rust prematurely affecting integrity of the rear lower control arm mounts. Back half of frame almost completely rusted through requiring a full frame replacement.

Our 2007 FJ Cruiser when brought in for annual inspection has been deemed unsafe for use due to crack in frame due to corrosion. The vehicle has no other mechanical issues and runs as if new. We invested in 5 new tires and now find ourselves possibly having to purchase a new vehicle. We witnessed all the other Toyota vehicles frames being replaced due to the recall regarding insufficient undercoating and excessive rust. We inquired if our vehicle was included and if there was reason for concern and were told No. We also own a 2010 Prius which we purchased new. We had no reason to question the validity of the answer. Years later we are grateful we did not experience any incident and crack was discovered before one happened. We now want to know why we did not get a replacement as did all the other models.

Rust is inherently bad on these vehicles. The other day i heard a weird noise under my truck driving down the road. As if I flung a rock up and hit a spring or something. To my dismay, I noticed the fuel tank hanging. One of the straps rusted to the point that it broke allowing the fuel tank to droop.

I recently purchased the used 2007 Toyota FJ with 101,000 miles. During maintenance and inspection, it was found that the fuel tank straps are rusted out and need to be replaced. The rear brake lines are rusted out and need to be replaced. The frame is severely rusted out and failing at the factory welds. I was referred to submit a report and investigate filing a class action lawsuit against the manufacturer for negligence, as this is apparently a known issue. I am hoping that the will reach someone that is able to help all the owners with the same issues as this should be recalled and repaired to prevent unnecessary injury or death. This is a huge financial burden for those expecting a quality vehicle that will be safe. Failing brakes, loose gas tanks and weakened frames are recipe for disaster.

the frame and associated components are severly corroded putting the vehicle in danger of the back axel detaching . i was informed of this by a repair shop who were concerned of the safety of operating vehicle. there is some type of coverage for related vehicles but not for this model. i think this is the same platform which was recalled under a truck model. toyota refuses any coverage or help for this problem. the vehicle has 70k miles but is unsafe to operate. photos are available. although the top of the vehicle is what you would expect with 70k miles, it is unsafe to operate because the back axel could fall off at any time

The frame on my 2007 Toyota FJ Cruiser has severe corrosion, compromising it's roadworthiness and the safety of occupants. It is available for inspection. Frame would not protect occupants during a crash, and may fail during normal operation. The problem has been confirmed by two independent mechanics. It has not been further inspected. There were no warning lamps or symptoms until discovered by mechanic. Anecdotal information seems to indicate broad and serious corrosion problems with FJ Cruiser frames, but no warnings, recalls, or service bulletins have been issued.

The contact owns a 2007 Toyota FJ Cruiser. The contact stated that the front driver’s side seat belt retractor and locking mechanism was inoperable, failing to secure the driver as needed. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 13V098000 (Seat Belts). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 100,000.

Backing out of my driveway we heard a slight pop and a dragging feel on the right passengers front.( thought I ran over a landscape brick) Stopped and inspected nothing was under the vehicle starting to leave my complex vehicle started to shake some. When I got up to 20 MPH it was obvious I should not drive. Called tow truck. Thought I needed ball joints or something similar. Mechanic said frame was completely rusted out and unfixable. The Toyota FJ cruiser is suppose to be a tough off road SUV which I never used for off road driving They even advertised how tough the frame is in commercials . I see there has been recalls for other Toyota models of SUV and trucks of the same year and their is a class action lawsuit already started I think in California. If I would have continued to the freeway A serious accident would had happened. I contacted Toyota and opened a case # [XXX] which after two communications they closed because there is no recall on the vehicle. The car is in great condition other wise. A frame should last more than 15 years on a truck \SUV designed for off road driving . her are some details of the pending lawsuit: Plaintiffs allege that a manufacturing defect causes excessive rust and corrosion to the frames of 2007-2014 FJ Cruiser vehicles. The suit claims the defect weakens the structure of the vehicle, therefore posing a serious safety threat to vehicle occupants. In some cases, vehicles failed to pass safety inspection and are no longer safe to drive. As a result, owners find themselves stuck with a vehicle that is no longer legally allowed on the roads with a greatly diminished resale value. Toyota Activity Marketed the FJ Cruiser with Special “Electrocoat Deposition” Rust Protection Coating Despite Toyota’s marketing highlighting the “Electrocoat Deposition” protective coating, plaintiff’s claim FJ Cruiser frames prematurely rust and corrode at an accelerated rate. The suit states Toyota had been aware of the frame defect, but fail INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

I was planning on trading in my FJ Cruiser, so I took it to our local mechanic to look it over. After he put it on the lift, he showed me that the frame and gas tank straps were rusted out and that it wasn't safe to drive. I took it to another body repair shop and after putting it up on the lift, he said he has never seen a frame so rusted out in his twenty five years of doing body work. I contacted Toyota and they said they would NOT repair the frame.