2004 Chrysler Pacifica Body & Structure Problems

UPON TAKING A THE VEHICLE TO A MECHANIC, I WAS INFORMED THE SUBFRAME WHICH SUPPORTS THE ENGINE IS RUSTING TO THE POINT IT WILL NOT HOLD THE ENGINE CAUSING CATASTROPHIC FAILURE. I HAVE BECOME AWARE CHRYSLER IS AWARE OF THE FUTURE FAILURE AND WILL NOT FIX IT.

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE FRAME RAIL WAS ROTTED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 141,000.

CAR RUNS AND DRIVES WELL. HOWEVER, OUR MECHANICE SAYS THE SUBFRAME IS RUSTED SO IT WILL NOT PASS INSPECTION.

Subframe/Engine Cradle failed due to rust. Subframe is available for inspection upon request. My safety or the safety of others is put at risk due to the failed (rusted, corroded, rotted) subframe/engine cradle. Vehicle’s engine is at risk of falling through the vehicle’s frame at any moment whether the vehicle is parked or being driven. This problem has been reproduced or confirmed by a dealer or independent service center. The vehicle and the subframe component has been inspected by a Master ASE Certified Mechanic. No symptoms of the problem prior to the failure that owner has ever been made aware of.

THE SUB-FRAME HAS RUSTED THROUGH, MY MECHANIC IS CONCERNED ABOUT THE POSSIBILITY OF THE ENGINE FALLING OUT IF NOT ADDRESSED. IT SEEMS TO BE A COMMON PROBLEM WITH THE PACIFICA MODEL BUT I DID NOT FIND OUT ABOUT IT UNTIL I TOOK IT TO MY MECHANIC TO FIND OUT WHY THE CAR WOULD "BOUNCE" WHILE DRIVING DOWN THE ROAD. IT IS ESPECIALLY NOTICEABLE WHEN THE CAR IS SHIFTING. HE WAS SHOCKED AT THE AMOUNT OF RUST HE FOUND UNDERNEATH.

FRONT FRAME CRADLE RUSTED OUT. WAS GETTING OIL CHANGED THE GARAGE I TOOK IT TOO BROUGHT IT TO MY ATTENTION THAT IS WAS VERY UNSAFE

TAKATA RECALL STATIONARY, RUSTED CROSSMEMBER

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. WHILE THE VEHICLE WAS AT TIRE DISCOUNTERS (7771 FIVE MILE ROAD, CINCINNATI, OHIO 45230, (513) 618-1613) FOR A ROUTINE OIL CHANGE, THE ENGINE CRADLE SUBFRAME WAS FOUND TO BE SEVERELY CORRODED. THE ENGINE CRADLE SUBFRAME WAS NOT REPLACED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED BY A DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 35,000.

I BOUGHT THIS VEHICLE USED AND THEN FOUND OUT THAT THE ENGINE CRADLE HAS A RUST HOLE IN IT WHICH MAY MAKE IT UNSAFE TO DRIVE. I ALSO LEARNED THAT IT IS A COMMON PROBLEM WITH THIS MAKE AND MODEL AND THAT CHRYSLER HAS NO INTENTION OF ADDRESSING THIS PROBLEM. CHRYSLER OBVIOUSLY MADE THIS PART SUB-STANDARD AND SHOULD PROVIDE A REPLACEMENT FOR THE SUBSTANDARD PART. IT IS DEFINITELY A SAFETY HAZARD.

I TOOK MY CAR IN FOR AN OIL CHANGE AND THE MECHANIC INFORMED ME THAT THE MAIN SUB FRAME WAS RUSTED AND MY CAR WOULD NOT PASS INSPECTION WITHOUT THIS BEING REPAIRED. I SEE THERE IS A MAJOR PROBLEM THAT CHRYSLER WILL NOT ADDRESS. I NEED HELP

CRADLE ROT. APPLY BRAKES & ENGINE SHIFTS FORWARD.

ENGINE CRADLE RUSTED OUT-HAD TO BE REPLACED. CHRYSLER FAILED TO PROPERLY COAT THE ENGINE CRADLES WHICH ALLOWED RUST TO DAMAGE THE CRADLES AND CREATE A SERIOUS SAFETY DEFECT.

THERE WAS A KLUNK IN FRONT END-TOOK TO MECHANIC-THE SUBFRAME ON THE VEHICLE IS RUSTED AND IS A SAFETY HAZARD.

SUBFRAME SEVERELY RUSTED TO INCLUDE AREAS AROUND BOLTS TO FRAME. APPEARS TO HAVE HAPPENED OVER TIME.

ENGINE CRADLE RUSTING THROUGH: I TOOK MY WIFE'S 2004 CHRYSLER PACIFICA WITH 185,000 MILES ON IT TO OUR LOCAL MECHANIC FOR A SMALL TRANSMISSION LEAK. ONCE HE GOT THE CAR UP ON THE LIFT HE NOTICED THE ENGINE CRADLE WAS RUSTING THROUGH. HE TOLD ME HE THOUGHT THERE WAS A RECALL ON IT. I WENT ON THE INTERNET AND SEEN THAT THERE WERE HUNDREDS OF FOLKS WITH THE SAME ISSUE. I CONTACTED CHRYSLER CASE NUMBER: 3571359 AND THEY TOLD ME I HAD TO HAVE A AUTHORIZED CHRYSLER SERVICE DEALER INSPECT THE VEHICLE AND THEY WOULD SEE WHAT THEY COULD DO. I TOOK OUR VEHICLE TO THE LOCAL CHRYSLER SERVICE DEALER AND HAD IT INSPECTED. THEY SAID THAT THE CRADLE WAS PERFORATED AND RUSTED THROUGH AND THAT IT WAS PAST IT'S WARRANTY BY YEARS AND MILEAGE. I SENT THAT INFORMATION TO CHRYSLER AND THEY EMAILED ME BACK AND SAID THAT THEY REVIEWED THE INFORMATION THAT THE DEALERSHIP REPORTED BUT IT WAS NOTHING THEY COULD DO. THE CAR IS PAST THE YEARS AND MILEAGE OF IT'S WARRANTY. I SENT THEM AN E-MAIL SAYING HOW DISAPPOINTED I AM ABOUT THERE DECISION TO DO NOTHING ABOUT AN ISSUE THEY KNEW THEY HAD. MY WIFE LOVES HER PACIFICA, WE HAVE OWNED IT OVER 12 YEARS. SHE BOUGHT IT AS A DEMO. IT STILL RUNS GREAT, IT STILL LOOKS GREAT AND EVEN WITH THE 185,000 MILES ON IT THE ONLY THING THAT IS WRONG WITH IT IS THE ENGINE CRADLE RUSTING THROUGH. I FEEL THAT THIS ISSUE COULD HAVE BEEN RESOLVED YEARS AGO IF CHRYSLER HAD SENT US A RECALL OR SOMETHING TO TELL US THAT THE CRADLE METAL WAS INFERIOR AND SHOULD HAVE BEEN REPLACED / REPAIRED SOONER BEFORE OUR WARRANTY RAN OUT. NOT TO MENTION THAT IT SHOULD HAVE BEEN A SAFETY CONCERN IF THE CRADLE WOULD HAVE RUSTED THROUGH AND THE ENGINE FELL OUT. I THINK THIS IS A COSTLY REPAIR THAT WE SHOULD HAVE NEVER HAD TO DO. I THINK CHRYSLER SHOULD HELP US WITH THE RESOLUTION OF GETTING OUR CAR REPAIRED SINCE THEY KNEW THERE WAS A PROBLEM AND DIDN'T TELL US.

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. THE CONTACT STATED THAT THE SUBFRAME TO THE VEHICLE WAS CORRODED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SUBFRAME FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER (NELSON AUTO GROUP CHRYSLER, JEEP, DODGE, RAM, 481 S. MAIN STREET, MT VICTORY, OH 43340) WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT SAFE TO DRIVE. A LOANER VEHICLE WAS PROVIDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND WOULD NOT ASSIST DUE TO THE EXCESSIVE MILEAGE ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 300,000.

DURING A STATE INSPECTION IN NOV, 2017, I FOUND OUT THAT THE ENGINE CRADLE FRAME, ON THE PASSENGER SIDE, IS RUSTED. I CALLED CHRYSLER TODAY, ON 800-992-1997, TO FIND OUT IF THERE IS A RECALL. SADLY I WAS INFORMED THAT THERE WAS NONE. THE STRANGE THING IS THAT NO OTHER PART OF THE CIRCLE SHOWS ANY RUSTED PART.

ROTTED SUBFRAME. ADVISED BY THE MECHANIC AT A ROUTINE OIL CHANGE THAT HE WOULD NOT DRIVE THE CAR.

I GAVE MY DAUGHTER MY 2004 CHRYSLER PACIFICA SO SHE WOULD HAVE A VEHICLE THAT WOULD TRANSPORT HER, HER TWO CHILDREN AGES 7 AND 2, HER HUSBAND AND FRIENDS, PETS AND/OR OTHERS. HER HUSBAND IS A MECHANIC AND AS SOON AS SHE GOT IT HOME HE LOOKED IT OVER AND REFUSED TO LET HER DRIVE IT. HE SAID THAT THE SUB-FRAME WAS RUSTED-OUT AND THAT IT WAS UNSAFE TO DRIVE. AFTER SOME RESEARCH INTO THE MATTER I DISCOVERED THAT WHAT HE REFERRED TO AS A SUB-FRAME WAS CALLED THE "ENGINE CRADLE" AND THAT THIS HAS BEEN A PROBLEM WITH THE PACIFICA(S). THERE WERE SERVICE BULLETINS SENT TO SERVICE CENTERS AND THAT CHRYSLER ACKNOWLEDGED A PROBLEM FOR THE PACIFICA BUILT FOR ONLY A FEW MONTHS. THE PROBLEM HAS OCCURRED ON MANY OTHER MONTHS AND YEARS. THE POTENTIAL FOR DEATHS AND INJURIES IS A REALITY! IF THIS ENGINE CRADLE WERE TO GIVE WAY AT SLOW SPEEDS THERE WOULD PROBABLY ONLY BE INJURIES TO THE OCCUPANTS, UNLESS ANOTHER VEHICLE WERE INVOLVED IN WHICH CASE MORE INJURIES AND DEATH COULD OCCUR. IF THE ENGINE CRADLE WERE TO FAIL AT HIGHWAY SPEEDS AND THE ENGINE HIT THE HIGHWAY I CAN ENVISION AN END-OVER-END CRASH THAT WOULD LIKELY KILL THE OCCUPANTS. IF THERE WERE OTHER VEHICLES INVOLVED THERE IS NO TELLING HOW MANY INJURIES AND DEATHS THERE MAY BE. I DON'T KNOW IF THIS HAS HAPPENED YET AND IF SO HOW MANY TIMES AND TO WHAT SEVERITIES, BUT MY DAUGHTER, MY GRANDCHILDREN AND SON-IN-LAW ARE NOT GOING TO BE VICTIMS. I SERIOUSLY HOPE THAT IT DOES NOT TAKE THE LOSS OF LIFE OR LIVES TO HAVE THIS POTENTIALLY DEADLY PROBLEM ADDRESSED AND CORRECTED. THE COST OF THE REPAIR IS HIGHER THAN THE WORTH OF THE VEHICLE AND THE MANUFACTURER MUST ABSORB THE COST THE REPAIR.

I HAVE CHRYSLER PACIFICA 2004. HAVE TAKEN GOOD CARE OF VEHICLE, NO ACCIDENTS. VEHICLE BEGAN SHAKING VIOLENTLY WHEN DRIVING DOWN ROAD. I HAVE BRAND NEW TIRES . HAD THEM REBALANCED COUPLE OF TIMES . STILL VIBRATING VIOLENTLY. MY MECHANIC COULD NOT FIND ANY PROBLEMS EXCEPT THAT ENGINE CRADLE FOR ENGINE IS BADLY ROTTED OUT WITH RUST. I LOOKED ON LINE FOR PROBLEM AND SEE THAT CHRYSLER HAD NOT PROPERLY COATED THE ENGINE CRADLE AND HAS LED TO FREQUENT PROBLEMS AND DANGEROUS DRIVING CONDITIONS, DUE THAT THE ENGINE COULD FALL OUT OF VEHICLE. THIS IS OF NO FAULT TO OWNER. I DIDNT FEEL SAFE DRIVING A VEHICLE THAT THE MOTOR COULD FALL OUT OF. THIS IS A SAFETY ISSUE THAT CHRYSLER SHOULD BE RESPONSIBLE FOR. A CONSUMER SHOULD NOT HAVE TO WORRY THAT THERE SEAT BELT OR AIR BAG MIGHT FAIL AND THEY DEFINITELY SHOUDNT HAVE TO WORRY ABOUT THERE ENGINE FALLING OUT OF THERE CAR WHILE DRIVING DOWN THE ROAD, WHICH COULD LEAD TO A WRECK OR FIRE. THANK YOU FOR YOUR TIME AND CONSIDERATION.