2002 GMC Yukon Engine Problems

TL* THE CONTACT OWNS A 2002 GMC YUKON XL. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED AFTER EIGHT ATTEMPTS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE CRANKSHAFT POSITION SENSOR WAS FAULTY. THERE WAS A RECALL ISSUED FOR THE 2001 GMC YUKON MODEL UNDER NHTSA CAMPAIGN ID NUMBER 07V521000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS CURRENTLY BEING REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 62,700.

BROKEN/LEAKING BRAKE LINES DUE TO SEVERE UNDERBODY CORROSION: FRAME,BRAKE AND GAS LINES, FRONT SUSPENSION, SPARE TIRE ASSEMBLY, NUTS, BOLTS, EXHAUST PIPES, ETC. ALONG WITH THIS I REPLACED TWO TRANSMISSIONS, ONCE DUE TO RADIATOR FAILURE, FUEL PUMP FAILURE, BRAKE CALIPER FAILURE, A FEW SETS OF REAR PARKING BRAKE SHOES BECAUSE THE ADJUSTMENTS DONT WORK PROPERLY, THREE WINDOW REGULATORS AND ALL WITHIN 163,630 MILES. YEA I'M PIS@#$ OFF. *TR

BROKEN EXHAUST MANIFOLD STUDS ARE CAUSING ENVIRONMENTAL HAZARD AND MAY LEAD TO FAILED CATALYTIC CONVERTER AND OTHER ENGINE PROBLEMS. THIS IS A MANUFACTURING DEFECT THAT SHOULD BE RECALLED, AS IT RENDERS THE VEHICLE EITHER UNUSABLE OR UNABLE TO PASS ENVIRONMENTAL TESTING. *TR

TL*THE CONTACT OWNS A 2002 GMC YUKON XL. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STOPPED ACCELERATING AND A BATTERY INDICATION LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE STALLED AND WHEN IT WAS RESTARTED, THE FAILURE OCCURRED AGAIN. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE CRANKSHAFT POSITION SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS BEING REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 116,000.

I HAVE A 2002 GMC YUKON XL. THIS VEHICLE THAT I RECENTLY PURCHASED HAS STALLED ON TWO OCCASIONS WHILE DRIVING. BOTH TIMES I WAS IN TRAFFIC AND HAD DIFFICULTY SAFELY GETTING OFF THE ROADWAY, AS I HAD NO POWER. I HAVE DONE A FAIR AMOUNT OF RESEARCH AND FOUND THAT I AM 1 OF MANY WITH THIS COMPLAINT. *TR

THE ENGINE CAN STALL INTERMITTENTLY AT HIGHWAY SPEED WITHOUT WARNING. THIS SITUATION CAN SEVERELY IMPAIR HIGH SPEED STEERING AND BRAKING ABILITY. AFTER STALLING ENGINE WILL NOT START WHILE COASTING IT WILL START NORMALLY AFTER COMING TO A COMPLETE STOP. *TR

ENGINE SHUTS DOWN WHILE DRIVING: I HAVE A YUKON XL 2002. OVER THE PAST 6 MONTHS THE ENGINE WOULD SUDDENLY SHUT DOWN WHILE THE CAR IS BEING DRIVEN. IT HAS OCCURRED AT HIGH SPEED AND AT LOW SPEED. I HAVE TAKEN IT BACK TO THE DEALER NO LESS THAN 5 TIMES AND THE PROBLEM PERSISTS. THIS REPRESENTS A MAJOR DANGER AS WHILE ON THE HIGHWAY, WHEN THE ENGINE SHUTS DOWN THE CAR BECOMES DIFFICULT TO MANEUVER AND MOVING OUT OF THE HIGHWAY TRAFFIC HAS BEEN EACH TIME EXTREMELY DANGEROUS TO ME AND TO OTHER DRIVERS. *TR

VEHICLE STALLS WHILE AT SPEED. HAS OCCURRED SEVERAL TIMES. MECHANIC FINDS NO PROBLEMS WITH ENGINE, COOLING SYSTEM, OR FUEL SYSTEM. IN EACH CASE, VEHICLE STALL RESULTED IN LOSS OF POWER, POWER STEERING AND POWER BRAKES, CREATING A DANGEROUS SITUATION. PROBLEM HAS NOT BEEN RESOLVED. *TR

TL*THE CONTACT OWNS A 2002 GMC YUKON XL. ON SIX SEPARATE OCCASIONS, WHILE DRIVING AT ANY SPEED, THE VEHICLE COMPLETELY SHUT OFF AND WOULD NOT RESTART IMMEDIATELY. THE VEHICLE WOULD SHUT OFF WHILE ACCELERATING FROM A TRAFFIC LIGHT OR STOP SIGN, AND WOULD NOT RESTART IMMEDIATELY. THE VEHICLE FAILED TO START ON A FEW OCCASIONS WHILE IN PARK. NHTSA CAMPAIGN ID NUMBER 07V521000 (ENGINE AND ENGINE COOLING) IS IDENTICAL TO THE FAILURE THE CONTACT IS EXPERIENCING. THE CURRENT MILEAGE WAS 76,000 AND FAILURE MILEAGE WAS 70,000. UPDATED 11/12/08. *LJ UPDATED 11/14/08. *JB

MY GMC YUKON 2500 WITH THE 8.1L STALLS WHILE DRIVING. THIS IS UNEXPLAINABLE AND UNREPEATABLE. THIS HAS OCCURRED PROBABLY 6 OR 7 TIMES AND IS A REAL DANGER AS YOU LOOSE POWER STEERING AND BRAKES. I BELIEVE IT IS THE CAM POSITIONING SENSOR. WHAT IS MY RECOURSE TO HAVE FIXED BY MANUFACTURER. *TR

TL*- THE CONTACT OWNS A 2002 GMC YUKON DENALI XL. WHILE DRIVING ABOUT 65 MPH UNDER NORMAL DRY CONDITIONS THE VEHICLE STALLED. THERE WERE NO WARNING SIGNS THAT THE VEHICLE WAS ABOUT TO STALL. ONCE THE FAILURE OCCURRED THE CONTACT LOST THE BRAKING SYSTEM AND THE POWER STEERING FAILED AS WELL. THE CONTACT WAS ABLE TO GET THE VEHICLE TO THE SIDE OF THE ROAD WITHOUT A CRASH. THIS FAILURE HAPPENED ON THREE OTHER OCCASIONS WITH OUT INCIDENT. THE VEHICLE HAD BEEN TAKEN TO THE DEALER WHERE THEY FIXED THE THROTTLE BODY AND WATER PUMP. THE FAILURE CONTINUED TO OCCUR AFTER THE REPAIR. THE CONTACT HAS THE REPAIR ORDER. THE CURRENT AND FAILURE MILEAGE WAS 98,000 .

VEHICLE STALLING WITHOUT REASON. OFTEN IN HEAVY TRAFFIC. MANUFACTURER USED PLASTIC INTAKE THAT FAILED DUE TO HEAT. $1050.00 TO REPLACE PART WITH SAME TYPE. WARRANTY FOR 12 MONTHS OR 12,000 MILES. PART COULD FAIL AGAIN AT MY EXPENSE. *JB

DT*: THE CONTACT STATED WHILE TRAVELING 75 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED AND THE MANUFACTURER WAS ALERTED. UPDATED 11/9/2006 - THE VEHICLE STALLED THREE TIMES IN ONE DAY AND ANOTHER TIME ABOUT 16 MONTHS AGO. THE CONSUMER WAS TOLD BY A SERVICE MANAGER THAT THE PROBLEM WAS WITH A COMPUTER RING IN THE KEY SWITCH ASSEMBLY. *NM

CAR STALLS WHILE TRAVELING DOWN HIGHWAY, OCCURS AT LEAST ONCE ON EACH TRIP. TIME OF OCCURRENCE IS BETWEEN 3 AND 30 MILES. SEVERAL TIMES IT HAS STALLED AND WOULD NOT RESTART WHILE IN MOTION, THOSE TIME TOOK SEVERAL MINUTES TO FIVE MINUTES TO GET IT RESTARTED. PROBLEM STARTED SIX MONTHS AGO AND HAS PROCEEDED GETTING WORSE. HAS BEEN SERVICED BY DEALERSHIP 5 TIMES SINCE FIRST TIME. THEY HAVE REPLACED SEVERAL ITEMS THAT HAVE NOT CORRECTED THE PROBLEM. WE HAVE HAD SEVERAL NEAR REAR END CRASHES AND SCARY MOMENTS WHEN ON THE INSIDE LANE OF AN INTERSTATE PULLING A 16 FT TRAILER. *JB

REF - PE06016 - VEHICLE STALLS WHILE AT SPEED. HAS OCCURRED THREE TIMES. MECHANIC FINDS NO PROBLEMS WITH ENGINE, COOLING SYSTEM, FUEL SYSTEM, BUT FINDS A DIAGNOSTIC CODE OF A CRANK POSITION SENSOR FAILURE. IN EACH CASE, VEHICLE STALL RESULTED IN LOSS OF POWER, POWER STEERING AND POWER BRAKES, CREATING A DANGEROUS SITUATION. PROBLEM HAS NOT BEEN RESOLVED BUT BASED ON OTHER REPORTS WILL REPLACE THE CRANK POSITION SENSOR. *NM

ORIGINAL PROBLEM: MY 2002 YUKON XL WAS RUNNING POORLY WHEN THE WEATHER TURNED COLD - BELOW 30 DEGREES. PROBLEM DIAGNOSED AS FAULTY INTAKE GASKETS DUE TO IMPROPER DESIGN. SECOND PROBLEM: IT BECAME HARD TO START, AND A COUPLE OF DAYS LATER, IT WOULD NOT START AT ALL. PROBLEM DIAGNOSED AS FAULTY FUEL PUMP. BOTH PROBLEMS ARE BECAUSE THEY WERE DESIGNED FOR USE WITH ETHANOL OR UNLEADED GAS. I ONLY USE UNLEADED (NEVER HAVE SEEN A STATION THAT SELLS ETHANOL). IF YOUR GM VEHICLE HAS A 5.3L V8 ENGINE, AND THE VIN HAS A Z IN THE 8TH POSITION, BE AWARE THAT THIS MIGHT HAPPEN TO YOUR VEHICLE. IF NOT UNDER WARRANTY, IT IS VERY COSTLY! THE GASKETS AND THE FUEL PUMP ALONE COST OVER $630. LABOR OVER $500. *NM

WHILE DRIVING 45 MPH VEHICLE LOST POWER. WITHOUT WARNING. DEALER COULD NOT DUPLICATE THE PROBLEM. *AK

WHILE DRIVING A LOUD KNOCKING NOISE WAS HEARD FROM THE FRONT. CONSUMER WAS ABLE TO DRIVE THE VEHICLE TO DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT A CARBON BUILD UP ON THE PISTON CAUSED THE KNOCKING. *AK

TL*THE CONTACT OWNS A 2002 GMC YUKON XL. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. IN ADDITION, THE VEHICLE WOULD STALL INTERMITTENTLY WHILE DRIVING AT VARIOUS SPEEDS. THE ENGINE WOULD COMPLETELY SHUT OFF. OCCASIONALLY, THE VEHICLE WOULD IMMEDIATELY RESTART, BUT OTHER TIMES, IT WOULD TAKE A WHILE. THERE WERE NO WARNING INDICATORS PRIOR TO THE FAILURE. THE VEHICLE STALLED THE MOST DURING DECELERATION. THE VEHICLE WAS TOWED ONCE AND THE DEALER MADE SEVERAL ATTEMPTS TO CORRECT THE FAILURE, BUT HAS BEEN UNSUCCESSFUL. THE CURRENT MILEAGE WAS 54,409 AND FAILURE MILEAGE WAS 14,523. UPDATED 04/29/08. *LJ THE CONSUMER STATED THE CRANKSHAFT POSITION SENSOR WAS REPLACED. THE CONSUMER STATED THERE HAVE BEEN NO FURTHER PROBLEMS. UPDATED

DEFECTIVE ENGINE (PISTONS KNOCKING IN CYLINDERS, AS DOCUMENTED BY DEALER) ON 2002 YUKON SLT; 19,500 MILES