Toyota · Tundra · 2003
10
Recalls
398
Complaints
-
Not Rated
The 2003 Toyota Tundra has 10 recalls and 398 owner-reported complaints on file with NHTSA. Most reported issue: structure (98 reports).
Source: NHTSA Public Records · Updated Apr 22, 2026
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2002-2005 Lexus SC and Toyota Sequoia, 2003-2005 Toyota Corolla and Tundra, and 2003-2007 Pontiac Vibe vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation.
Remedy Status
Toyota will notify the Toyota and Lexus owners. General Motors will notify the Pontiac Vibe owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator with an alternate inflator, or replace the air bag assembly that includes an alternate inflator, free of charge. The recall began January 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371, Lexus customer service at 1-800-255-3987 or Pontiac customer service at 1-800-762-2737. Toyota's numbers for these recalls are J0A (Zone A Toyota), J0B (Zone B Toyota), J0C (Zone C Toyota), JLI (Zone A Lexus), JLJ (Zone B Lexus), and JLK (Zone C Lexus). Note: This recall includes vehicles that have had their air bag previously replaced under an earlier air bag campaign.
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Remedy Status
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE A MANUAL AIR BAG ON-OFF SWITCH TO DISABLE THE FRONT PASSENGER AIR BAG AND DO NOT HAVE A CHILD RESTRAINT LOWER ANCHORAGE SYSTEM IN THE FRONT PASSENGER SEAT. THIS SPECIFICATION DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy Status
DEALERS WILL REMOVE THE MANUAL AIR BAG ON-OFF SWITCH, REPLACE THE OWNER'S MANUAL, AND AFFIX A NEW SUN VISOR AIR BAG WARNING LABEL. THE RECALL BEGAN IN EARLY JANUARY 2007. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Remedy Status
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
TOYOTA IS RECALLING MODEL YEAR 2000-2003 TUNDRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA. EXCESSIVE CORROSION OF THE REAR CROSS MEMBER MAY CAUSE THE SEPARATION OF THE SPARE TIRE STOWED UNDER THE TRUCK BED WHICH WOULD PRESENT A ROAD HAZARD THAT COULD CAUSE A CRASH. ALSO, CORROSION OF THE REAR CROSS MEMBER COULD AFFECT THE REAR BRAKE LINES AND THE PROPORTIONING VALVE RESULTING IN DIMINISHED BRAKING CAPABILITY.
Remedy Status
TOYOTA IS ASKING OWNERS OF THE AFFECTED VEHICLES TO REMOVE THE SPARE TIRE FROM UNDER THE VEHICLE UNTIL A REMEDY CAN BE OBTAINED. DEALERS WILL INSPECT THE REAR CROSS MEMBER AND RELATED COMPONENTS, INCLUDING THE BRAKE LINES, AND REPLACE THEM IF NECESSARY. IF THE CROSS MEMBER DOES NOT NEED TO BE REPLACED, IT WILL BE SPRAYED WITH A CORROSION PROTECTION COMPOUND. THESE SERVICES WILL BE PERFORMED FREE OF CHARGE, HOWEVER MULTIPLE VISITS TO THE DEALER MAY BE REQUIRED. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT APRIL 30, 2010. OWNER MAY CONTACT TOYOTA AT 1-800-331-4331.
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Remedy Status
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Remedy Status
Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.
Remedy Status
DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004. On June 16, 2015, Toyota expanded the recall to include an additional 1,270,468 vehicles, including model year 2002-2003 and 2005-2007 Sequoia, 2005-2006 Tundra, 2003-2007 Corolla, 2003-2007 Corolla Matrix, 2003-2007 Pontiac Vibe and 2002-2007 Lexus SC vehicles. This is to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.
Remedy Status
2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-285 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the front passenger air bag. The recall began on July 13, 2015. Toyota owners may contact Toyota customer service at 1-800-331-4331. Pontiac owners may call 1-800-762-2737. NOTE: This recall supersedes recall 14V-312 in its entirety.
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. On June 16, 2015 Toyota expanded the recall to cover an additional 769,055 vehicles, including certain model year 2002-2004 Lexus SC, Toyota Sequoia, 2003-2004 Toyota Corolla Matrix, Toyota Corolla, Pontiac Vibe, and Toyota Tundra vehicles, as well the vehicles covered by the May 13, 2015 notification in the portions of Georgia, Alabama, Louisiana, Mississippi and Texas that were not previously included. The inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.
Remedy Status
2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-286 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the passenger side front air bag, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota began the recall on July 13, 2015. Pontiac Vibe owners may contact GM at 1-800-762-2737. GM began the recall on June 29, 2015. NOTE: This recacll supersedes recall 14V-655 in its entirety. For vehicles located in the U.S. states not listed above, please see Toyota recall 15V-285 which covers all other U.S. states.
NHTSA Campaign 09V444000 for 2000-2003 Toyota Tundra to address severe corrosion on the rear frame cross-member section or rear brake lining proportion valve. Vehicle was apparently treated with CRC in 2010, but vehicle continued to rust severely in the specified recall zone, even after Toyota Safety Recall 90M had been completed on the vehicle. The CRC applied to the rear frame cross-member of the frame as specified did not inhibit further corrosion of the rear frame cross member, if anything it accelerated the corrosion. Thousands of 2000-2003 Toyota Tundras titled in the specified severe cold weather states still remain in use, and pose a threat to the overall safety of drivers. The Toyota 90M Safety recall did not adequately inhibit the corrosion of the rear frame section, rendering the vehicle unserviceable & unable to align, and leaving gas tanks, rear suspension, rear drive train, and spare tire parts susceptible to falling off of the vehicle and causing an accident- posing a risk of severe injury/death to road users. I am asking that the NHTSA please look into reissuing the NHTSA Campaign 09V444000 to have all 2000-2003 Toyota Tundras still registered for road use in severe cold weather states be inspected by a certified Toyota dealership for repairs, frame replacement, or vehicle buybacks to prevent unnecessary accidents due to a manufacturer defect that was never rectified properly.
I own a 2003 Toyota Tundra (VIN: [XXX] ) that was subject to Toyota’s frame corrosion recall (Limited Service Campaign A0F). The vehicle was inspected by Toyota in January 2011 and confirmed to have no perforation. In March 2012, Toyota applied a corrosion-resistant compound as part of the recall remedy. Despite this, by May 2013, a structural component (spare tire carrier) failed due to severe rust and detached from the vehicle. This occurred shortly after Toyota performed the corrosion protection treatment. This raises concerns that the recall remedy was not effective in preventing continued structural deterioration. Frame corrosion can impact vehicle safety, especially if critical components weaken or detach. Toyota has declined any further review or assistance, stating the program has expired, despite evidence that the corrosion continued after their repair. I am submitting this complaint to request investigation into the long-term effectiveness of the corrosion protection remedy applied under this recall program. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Getting Airbag light on . Went to Modesto Toyota and they installed new clock spring strap in steering wheel. After installing the airbag light came back on . I again went back to dealer with same issue. They installed another clock spring in steering wheel. Drove about 1 mile , again airbag came on. Took it back to dealer a 3rd time same issue. They told me that the connector for the strap was too short. So now I am in limbo waiting for a replacement or something. Contacted dealer Modesto Toyota today 4/16/2026. No response as of yet. So I have still have the airbag light on.
The frame was undercoated incorrectly and is actively falling apart. Super unsafe to drive. Very clearly was not undercoated correctly as there is areas in the frame that have no signs of undercoating. This is putting the driver of the vehicle at risk as well as the other drivers on the road. This is a huge recall that was issued for this model of year truck. Very common. The vehicle has not been inspected by the dealer as they refused to inspect it or even acknowledge the issue. There is no warning lamps on but it is visibly unsafe to drive
The frame was not professionally undercoated and is actively falling apart. Super unsafe to drive.
There was a recall for the frame rusting out prematurely. Toyota had the recall until 2012. I did not own the truck then and it did not get fixed. Now I have a rusted out frame. Toyota is claiming they are not able to fix the frame due to it being 14 years later. They would however be able to keep the recall open if it is a safety recall. I don't know how a rusted out frame wouldn't be anything other than safety. The truck has less than 80,000 miles. What automobile should have a rusted out frame with less than 100,000 miles?!
The frame is bad on driver and passenger side between the cab and bed. Auto body tech states there is no good metal to make the necessary repairs (welding new metal) to at this time. Inspection garage states it is a solid truck but will not pass inspection due to the frame’s condition. The vehicle has 106k miles on it with one surface area of rust. The vehicle has been well maintained and is mechanically in good condition. Toyota should have replaced the frames because they knew there was an issue. Can NHTSA help with a resolution?
Frame Corrosion: There was originally a customer service campaign for 2000-2003 Toyota Tundra’s for frame corrosion that was extended under administration tracking code “BXD.” My vehicle was manufactured in Indiana and has major frame rust on the rear cross member portion of the frame. This extension has no expiration date and the vehicle has excessive damage to the frame. Please help authorize the replacement of this frame as the vehicle only has 150,000 miles and has a clean title. Any help would be appreciated.
Well I finally paid off my 2003 Toyota Tundra and I wanted to really just get a really good tune up when I say really go I mean oil change spark plugs plug wires brakes tires everything , So as they go to check my tires and brake They said that the brakes on the front didn't even go to my truck the rotors everything and that is a really big issue so now I can't get my front brakes repaired because they don't understand why those parts are on my vehicle when they shouldnt be and I need to know what to do?
I need to have rear shock replaced. They found that the bracket holder rusted thru . Shock was fine . The Rear frame corrosion and separation, spare tire frame corrosion is really bad. I have had this truck since 2004 . I absolutely love my truck. I am deeply saddened that all the care I took still didn’t prevent all this damage .
Frame rusted out causing gas tank to fall off truck while driving. Was sparking while trying to pull of to a safe spot on highway, tank was hanging on by the fuel line. Leaf spring also broke on truck do to rust. Cars were avoiding my truck on highway as sparks were coming from the gas tank shield scrapping the highway. Frame should have been replaced along with gas lines, and leaf springs during the recall in 2012 range. Toyota of York decided to just undercoat spray frame, prior to me purchasing truck from them. They never notified me (the consumer) of the recall that was current on truck.
The 2003 Toyota Tundra is known for severe frame rot due to improper rust protection, which led to a major safety recall. The excessive corrosion can cause rust holes to form in the frame, compromising the vehicle’s structural integrity. This can lead to frame cracking or even complete failure, making the truck extremely dangerous to drive. A weakened frame affects the vehicle’s ability to absorb impact in a crash, reduces stability, and can lead to suspension or steering failure. In extreme cases, parts like the fuel tank or spare tire can detach, increasing the risk of a serious accident.
The contact owns a 2003 Toyota Tundra. The contact stated while in the process of selling the vehicle, the potential buyer inspected the subframe and informed the contact that the frame was severely rusted inside and outside. The vehicle was taken to an independent mechanic, where it was inspected. The mechanic confirmed the failure and informed the contact that the six bolts holding the bed securely were severely rusted. The contact was provided an estimate for a partial external repair of the subframe. The vehicle was not repaired. The contact stated that the dealer had previously sprayed a corrosion protective compound on the vehicle under NHTSA Campaign Number: 09V444000 (Structure); however, the failure progressively worsened. The dealer and the manufacturer were notified of the failure. The vehicle was not repaired. The failure mileage was approximately 119,000.
Frame cross member recall, I have called several toyota dealerships and all have denied me service to the recall
In October 2024, my truck's frame exhibited significant rust, a defect that aligns precisely with a previous recall on this model. The rust has spread to critical parts, making the vehicle unsafe to drive. This directly threatens the safety of my son, who relies on this truck for transportation. The rust compromises the frame's integrity, risking structural failure and potential loss of vehicle control. This defect was not previously flagged by warning lamps or messages and was only recently discovered through visual inspection. This issue has been documented in the past and is consistent with a recall initiated a year ago. This recall specifically cited frame rust as a critical defect, and my vehicle is one of those affected models. Given the safety concerns, the severity of frame rust, and the recall history, the frame needs immediate replacement. This action is crucial to ensure my son's safety and prevent potentially life-threatening incidents on the road.
On 4/19/2024 I arrived for an appointment at Corwin Toyota of Bellvue, Nebraska for inspection of my vehicles known recall of the frame due to excessive rust and potential failure due to a faulty manufacturing process. My vehicle is a 2003 Toyota Tundra SR5, Access Cab. Upon arrival, the service representative, and later corroborated by his manager, refused to inspect my vehicle stating "work had already been done on my frame". That is not true. I am the original owner of said vehicle and had it inspected in approximately 2010 after being informed of the recall, likely at a dealership in Denver Colorado where i was residing at the time. At that time was informed vehicle frame did not have excessive rust and NO work was done. The vehicle was purchased in Colorado Springs from Corwin Toyota (same dealership franchise company?), in 2003. Since then, the vehicle has lived in Nebraska and Iowa for most of its existence where salt is used on roads extensively in the winter. I was informed by the service representative at the dealership they will not look at it as they show it has already had repairs done to the frame as I stated. This is false. No work has been done on my vehicles frame at any point and is now experiencing significant frame rust. At some point, maybe at inspection in 2010, maybe later, that some work had been done making the frame ineligible for future inspection or repair or replacement. I am sure Toyota and its agents, Toyota dealerships, are highly motivated to exclude as many vehicles associated with this frame recall as possible. I am certain I am not the only one experiencing this fraud on the consumer. Please investigate whom allegedly did work on my frame, when, and what specifically. I expect the ability to have my frame legitimately inspected and actual repairs or replacement of effected part(s) as resolution. I will be contacting the manufacturer but expect the same run around without your direct involvement. Thank you in advance.
rear leaf spring mount separated from the frame due to complete rust -through of the frame. felt a "thump" during normal acceleration.
I have a 2003 Toyota Tundra with a Rusted out frame, I have called Toyota with no help from them as it was Sorry its your problem.. I need Help Toyota, this is my only transportation. I BOUGHT YOUR PRODUCT IN GOOD FAITH, Please stand behind your product.
I just bought the Toyota I was told that he had brought this Toyota to a dealership and it was sent to har some sealant sprayed on frame to prevent anymore rust. The whole frame and the spare tire holder thing is total rusting out and the motor mounts are even rusting out is there a recall on his veichle if not there should be
Both rider and driver seat belt become unlatched randomly. I have no expectation these will remained secure if involved in an accident
Showing 1–20 of 25 complaints
The 2003 Toyota Tundra has 10 recalls recorded by NHTSA.
NHTSA has received 398 owner-reported complaints for the 2003 Toyota Tundra.
NHTSA has not published a safety rating for the 2003 Toyota Tundra.
The most commonly reported complaint categories for the 2003 Toyota Tundra are structure (98 reports), air bags (69 reports), power train (23 reports).
Yes. NHTSA has 10 recalls on record for the 2003 Toyota Tundra. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.