2021 Ford Bronco Sport Steering Problems

The contact owns a 2021 Ford Bronco Sport. The contact stated that while starting the vehicle, the message "Faulty Battery and Charging System" flashed on the screen, and the vehicle failed to immediately start. The contact stated that while driving later, several messages, including the messages "Faulty Power Steering" and "Faulty ABS" were displayed, and the vehicle suddenly stalled and failed to restart. The vehicle was towed to the local dealer. The vehicle was not yet diagnosed or repaired. The contact was informed that the VIN was not included in NHTSA Campaign Number: 24V267000 (Electrical System, Power Train), which the contact related the failure. The manufacturer was not yet contacted. The failure mileage was 56,000.

Vehicle chutters especially turn low speed turns and after stopping and making turn. You can feel vibration in the steering wheel and can be jerky turning. I have read of multiple other reports of this happening to vehicles and there is a TSB (24-2185)out for the repair. Ford knows about it and should be liable for the fix.

The contact owns a 2021 Ford Bronco Sport. The contact stated while attempting to make a left turn, the front and rear end of the vehicle was shaking abnormally. The contact stated that neither a dealer nor an independent was contacted. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The contact related the failure to an undisclosed Technical Service Bulletin; however, the vehicle was not included. The manufacturer was notified of the failure and opened a case. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 24,900.

The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at various speeds over puddles, the vehicle shuddered and made an abnormal sound. The contact stated that while the dealer was servicing the vehicle, the dealer informed the contact that the power steering gear was detaching. The dealer determined that the steering rack and gear and the tie rods needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was not notified of the failure. The failure mileage was approximately 77,000.

I was driving 70mph on [XXX] in New Jersey when all of a sudden with no prior warning the battery light came on and my vehicle became very hard to control, I felt it shutting down so I immediately pulled to the only shoulder which happened to be on the left. The car shut down and would not start again. A State Trooper said I can not stay on the left shoulder and decided to push my car to the next exit. Since it was an electrical problem my car kept locking up and would not stay in neutral and the steering kept locking as well. I was being pushed on the left shoulder with car speeding past me while my car was locking up which also cause my tires to blow out, I was afraid for my life but the officer continued to push me. This is the second time my vehicle shut down on me leaving me in a dangerous situation, I'm afraid that next time it happens It could cause me to get seriously injured or my life! I had to have it towed to the dealership and I was charged almost $1000 for repairs and 2 weeks later I received a recall letter on this issue for the software. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My ford bronco stalled when I was slowing down at a traffic light. The entire car shutdown. The steering wheel locked up and the car could not be put into neutral. After about 15 minutes the car was able to turn on again. The stalling out at an intersection put me in danger by putting me in a situation where I was stuck in active traffic without the ability to move my car to a safe area off of the main road. There were no warning lights or messages prior to the car completely shutting off at the traffic light.

When turning at low speeds like a drive-thru or in a parking lot, the vehicle makes a skipping or grabbing sound and pulls/lurches slightly until the wheels are straightened. Recommended fix was replacing a front differential ventilation hose, which is not covered by bumper-to-bumper or powertrain warranty, and not a guarantee to fix the issue.

REAR DIFFERENTIAL- CAR IS SHUDDERING WHILE TURNING- SAFETY ISSUE

In 2021 i purchased a brand new Bronco Sport Big Bend with the hopes that it will last as long as the previous Bronco models. Unfortunately, 3 years later i took the vehicle to a Ford dealership, and to my surprise the transmission needs to be replaced. Being a vehicle that is regularly driven by my pregnant wife is an issue that Ford needs to be accountable for. There were no engine lights on, the only warning was a noise i noticed when driving the vehicle myself in the highway. I understand that transmission failed throughout the course of the years, but to a 3 year old Ford Bronco Sport is just ridiculous and not safe at all. The vehicle is currently at the dealership, Ford has agreed to pay 5k towards the replacement but i still have to come up with more than 7k to get it fix. If i knew i would be having Transmission issues so early in the life of the vehicle, i wouldn't have purchased a new car in the first place. This is definitely a safety hazard and i am sure this is not the only Bronco Sport with a torque converter being faulty, causing the transmission to slip.

While driving on the highway at 65 mph the vehicle completely shut off. All electrical components stopped working as well. After the recall was “fixed” it still randomly will not turn on. This car is a horrifying death trap and should be recalled completely, this is incredibly unacceptable for use and terrifying to drive. I was lucky there were no other cars around me at the time.

My son and I slowed at a light to turn right. The vehicle completely shut down in traffic. We couldn’t put the car in neutral. We couldn’t turn the hazard lights on and couldn’t jump the vehicle. Luckily we were going slow traveling approx 10-15mph. Our emergency jump machine eventually worked after about 10 minutes, but the console screen remained blank and we drove straight to the dealer, but on Saturdays they don’t have any actual maintenance. The only thing they said they can do is test the battery. After a search on the internet, this has happened to lots of people. Some 2021 Ford Bronco Sports have been recalled, but mine isn’t listed. My question to Ford is, if this is a known issue why are they risking people’s lives? Again luckily we weren’t on the highway or even busier traffic.

This newer 2021 Ford Bronco Sport stopped working and lost all power on Feb 21, 2024. The vehicle had just 37,031 miles on it. To problem solve, A neighbor jumped it. I turned the vehicle off after a few minutes and it would not turn over and start again. We jumped it again and let it run for about 10-15 minutes. Thinking it was safe to drive, I turned out of my parking lot thinking it was fine and the vehicle began to shake and putter as though it was losing power. It felt unsafe to drive it so I pulled back into my driveway and had it towed to the dealership for repair. Ford dealer told me it was the battery. Since then I’ve had issues with the drivers side window getting stuck when rolled all the way down, sometimes the vehicle has a hard time “catching” to start when I press the break and the power button simultaneously, it also feels like its lulling into between gears when I am going at a low speed. Basically the Vehicle feels like there is an electronic issue. I paid $517.50 for a new battery and labor. A battery should not be failing at 37k miles on a car that was bought brand new. I’ve leased and bought brand new cars since 1992 and I’ve never had to replace a battery on a new vehicle. Now, for the past week, this vehicle feels very tight and sounds like it’s almost grinding when I turn right or left out of my parking stall at home. It feels like there is a power train issue .

There is a load moaning sound when backing the vehicle up or making a turn which significantly effects steering and stoping. Ford dealership said that tires were not rubbing body and tie rods were ok. This ford bronco sport only has 25K miles on it and never taken off road. Ford said to live with the sound until it bothered us? They said that it didn't need brakes but a new brake job could possibly fix problem? Independent repair shop said that it wasn't a brake issue but didn't know what the problem was. This load sound must be a defect for this vehicle because others on the web have expressed the same problem but ford has not put out a recall as of this date.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while reversing, there was an abnormal grinding noise detected coming from the brakes. While driving at various speeds around a curb, the steering wheel was jerking. There were no warning lights illuminated. The vehicle was taken to the local dealer and the mechanic was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not contacted. The approximate failure mileage was 9,000.